Professional Documents
Culture Documents
Saab Front Fender Replacement.
Saab Front Fender Replacement.
Saab Front Fender Replacement.
Front wing
Removing
2. Remove the wiper arms. Use 85 80 144 Puller, windscreen wiper arm.
3. Remove the rubber seals and the bolts holding the cover of the bulkhead partition
space. Remove the cover by lifting the front edge and then pulling forward so that
the clips release from the edge of the windscreen. The lift it rearwards and remove
it.
4.
8.
Remove the bolts from the radiator crossmember mounting (behind the direction
indicator lamp).
10.
Slightly loosen the screws on the A-pillar so that the wing can be pushed forwards.
11. Unscrew the nut holding the scuff plate to the front wing.
12. Pull out the scuff plate and slide the front wing forwards. Lift away the front wing.
Note
Left-hand front wing: Fit the VIN plate to the new
wing after painting. Transfer over any
modification identity plate.
Fitting
1. Push the wing lugs into position behind the screws in the A-pillar while pulling out
the scuff plate.
3.
5. Fit the sound insulation behind the front wing at the A-pillar.
6. Insert the side direction indicator cable into the wing and connect it. Fit the lamp in
the front wing.
7. Fit the bolts in the radiator crossmember mounting (behind the direction indicator
lamp).
9.
11.
Place the cover over the bulkhead partition space by pressing on the clips under the
windscreen and inserting it inside the windscreen moulding on the A-pillar. Screw on
the cover.
13.