Professional Documents
Culture Documents
Tech Note 343 - Setting Up The DAServer User Account For Administrator Privileges
Tech Note 343 - Setting Up The DAServer User Account For Administrator Privileges
Tech Note 343 - Setting Up The DAServer User Account For Administrator Privileges
Introduction
There may be an occasion where you successfully install one of Wonderware's DAServers, but the DAServer will not show up in the System Management Console under your local pc. This happens because the account that the DAServer used during the install didn't have administrator privileges. The following steps will setup the DAServer account so that it has Administrator privileges.
Detailed Steps
1. Launch the Control Panel and select Add/Remove Programs (Figure 1 below):
Figure 1: Add/Remove Programs 2. 3. 4. Click Remove to uninstall the DAServer. Open up the DAServer Admin user utility located in C:\Program Files\Common Files\ArchestrA\ aaAdminUser.exe. Enter a User account and password with Administrative privileges (Figure 2 below):
Strona 2 z 3
Figure 2: Admin User Utility 5. 6. Click OK. Reboot the computer and re-install the DAServer. Your System Management Console should now look like the following figure (Figure 3 below):
Figure 3: SMC Note: You may not have all the DAServers installed as you see in the above screen, but you should see the ones that you did install.
D. Plesset
The Tech Note is published occasionally by Wonderware Technical Support. Editors: Sabrina Abercromby and Kelly Hauser; Publisher: Wonderware Corporation, 100 Technology Drive, Irvine CA 92618. There is also technical information on our software products at
Strona 3 z 3
www.wonderware.com/support/mmi, our WonderFax fax-on-demand system at (949) 450-5050, and the Comprehensive Support Knowledge Base.