Professional Documents
Culture Documents
Micro Electronics
Micro Electronics
Find the value of the dc output voltage, ripple voltage, conduction interval and conduction angle for the circuit having a secondary voltage of 12.6 Vrms ( 60 Hz ) with R = 15 C = 25, 000 F Assume the diode on-voltage Von = 1 V .
2.
4993-example 5.34 Design the stage of the circuit given below to satisfy the following conditions: I C = 1 mA . Voltage drop across RL = 400 mV . Voltage gain =20 in the audio frequency range (20 Hz to 20 kHz). Input impedance > 2 k . Assume = 100 I S = 5 1016 A VCC = 2.5 V
3)
4993-8-18Example Design the non-inverting amplifier shown in the figure below for the following specifications. Closed-loop gain =5. Gain error = 1% Closed-loop band width = 50 MHZ.
Determine the required open-loop gain and bandwidth of the operational amplifier. Assume the operational amplifier has an input bias current of 0.2 A .
4)
4993-Example 9.16 Compute the error in I copy1 and I copy 2 in the below figure, before and after adding a follower.
Where, AE and 10 AE denote one unit and 10 unit transistors respectively. Calculate I copy1 if one of the four unit transistors is omitted, that is, the reference transistor has an area of 3 AE .
5)
4901-18-3Example Find the small-signal gain, input and output resistance of the amplifier in the figure below for the idealized case with Ri = . Use F = 150 VA = 50 V