Professional Documents
Culture Documents
ICT 07A1EC05 Network Analysis
ICT 07A1EC05 Network Analysis
ICT 07A1EC05 Network Analysis
ICT
NETWORK ANALYSIS
(Electronics & Communication Engineering)
Time: 3 hours Answer any FIVE questions All questions carry equal marks **** (a) Explain the active elements in detail (b) 10 A
Max Marks: 80
0
2 4 6
10
t sec
(a) Derive the expression for form factor of a sinusoidal current wave form. (b) An inductor 0.1H in series with resister 15 ohms connected across 230 V, 50 Hz, 1AC supply Find (i) current through the circuit ( ii) Power factor of the circuit (iii) Voltage across the circuit.
(a) Derive the relation between phase and line values of a 3 system.
(b) Given a series RLC circuit with R=100 ohms, L =0.5 H and C = 40 resonant, upper and lower half-power frequencies. 4
(a) By taking any one example write down the procedure to obtain dual networks and also draw the dual network. (b) By taking any one example draw graph, tree and select a tree and write tie set schedule.
(a) State and explain Tellegins Theorem. (b) By using Nortons Theorem determine current through 10 resister. 7 5 A 10
6 10v
B Contd. in page 2
Page 1 of 2
Code: ICT07A1EC05
ICT
(a) Define and obtain Hybrid parameter. (b) A two port network has the following parameters and calculate short circuit parameters. , , ,
(a) Derive the expression for current when DC voltage V is applied suddenly by closing a switch in a series R-L circuit. (b) A series R-L circuit with R= 50 and L = 0.2 H has sinusoidal voltage of v=150 sin . Find the expression for total current. (500++ ) V applied at a limit when
(a) Write short notes on Low Pass filters. (b) Design m-derived high pass filter having design impedance of 450 ohm, cut off frequency 3 KHz and infinity alternation at 2.7 KHz
*****
Page 2 of 2