The document provides instructions for removing and installing an instrument cluster in a vehicle. It cautions that module configuration information must be uploaded from the old module and downloaded to the new one. The steps are: (1) lower the steering column, (2) remove the finish panel, (3) remove components in order shown in an illustration including screws, indicators, connectors and cluster, (4) install in reverse order, and (5) download configuration information to the new module.
The document provides instructions for removing and installing an instrument cluster in a vehicle. It cautions that module configuration information must be uploaded from the old module and downloaded to the new one. The steps are: (1) lower the steering column, (2) remove the finish panel, (3) remove components in order shown in an illustration including screws, indicators, connectors and cluster, (4) install in reverse order, and (5) download configuration information to the new module.
The document provides instructions for removing and installing an instrument cluster in a vehicle. It cautions that module configuration information must be uploaded from the old module and downloaded to the new one. The steps are: (1) lower the steering column, (2) remove the finish panel, (3) remove components in order shown in an illustration including screws, indicators, connectors and cluster, (4) install in reverse order, and (5) download configuration information to the new module.
413-00-1 Information, Gauges and Warning Devices 413-00-1
REMOVAL AND INSTALLATION
2. Remove the instrument cluster finish panel. Instrument Cluster Refer to Section 501-01.
3. Remove the components in the order indicated
CAUTION: Prior to removal of the in the following illustration and table. module, it is necessary to upload module configuration information to the diagnostic tool. This information needs to be downloaded into the new module once installed. For additional information, refer to Section 418-00.
CAUTION: Electronic modules are
sensitive to electrical charges. If exposed to these charges, damage may result.
1. Lower the tilt steering column to the lowest
position.
Item Part Number Description Item Part Number Description
413-00-2 Information, Gauges and Warning Devices 413-00-2
REMOVAL AND INSTALLATION (Continued)
Item 4: Instrument Cluster Installation Note Item 5: Instrument Cluster Lens Removal Note 1. Following installation of the new instrument 1. Release the tabs on the top and bottom of the cluster, download the module configuration instrument cluster and remove the lens. information from the diagnostic tool into the new module. For additional information, refer to Section 418-00.