Professional Documents
Culture Documents
Engine Speed Sensing Power Steering: Power Steering Oil Pump (F2 Cis, F2 Carb, G6) Disassembly/Assembly
Engine Speed Sensing Power Steering: Power Steering Oil Pump (F2 Cis, F2 Carb, G6) Disassembly/Assembly
POWER STEERING OIL PUMP (F2 CIS, F2 CARB, G6) DISASSEMBLY/ASSEMBLY 1. The following procedure is for replacement of the O-rings only. Replace the pump component if other repairs are necessary. 2. Disassemble in the order indicated in the table. 3. Assemble in the reverse order of disassembly.
G6
R F2 CIS
5068 {5.07.0, 3750}
F2 CARB
1623 {1.62.4, 1217}
SST
Nm {kgfm, ftlbf}
1 2 3 4 5 6 7 8 9 10 11 12
Power steering oil pump component + Disassembly Note Pressure switch component O-ring Nut (G6) Connector (G6) Connector bolt O-ring Control valve component Spring Suction pipe O-ring Shaft component
13 14 15 16 17 18 19 20 21 22
Rear body + Assembly Note O-ring Cam ring + Assembly Note Rotor Vane + Assembly Note Pin Side plate + Assembly Note O-ring Oil seal Front body
N19
49 F032 301
ROUND EDGE
Rear Body Assembly Note D After installing the rear body, manually turn the shaft to verify that it rotates smoothly. Side Plate Assembly Note 1. Install a new O-ring and the side plate to the front body. 2. Position the side plate using the rear body.
Vane, Cam Ring Assembly Note 1. Install the cam ring with the marks facing the front body.
2. Install the rotor with the mark facing the rear body.
MARK
N20