Uda A

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

NOTES: 1. WARNING! Using a non-factory RS232 data cable may result in damage and may void system warranty.

2. All installations in hazardous locations must comply with requirements of certification drawing 2015246-CD.

RS-232 Comm Term Bd P/N 2101059-002 or P/N 2100888-002


J2

Typical Radio Mounting Position


1

DCD PIN 1 TO 2 CTS PIN 2 TO 3

Use DCD For Typical Operation

J6
J7 + -

BAT

TB1

J2

5 6

TB2

CHRG

BLK (GND) BLU (V-BATT) BRN (RXD) GRN (TXD) WHT (SWVBATT)

Totalflow Cable Assy P/N 2101238-003

J4

GRA (GND)

Radio Rotated 90 For Clarity

2 (-) 1 (+)

P2

RXD TXD SLEEP (GND = SLEEP) GND

2 3

4 5

P1

Diagnostic Port
To Antenna

uFLO Board 2100767-001

560 OHMS

PRIMARY SETUP ITEMS FOR TRANSNET 900 RS-232 RADIOS: 1. Mode R. 2. ADDR XXXX - where (xxxx) is radios address, which is also the same as the Master Radios Address. 3. SLEEP ON. 4. Port RS232. 5. BAUD 9600 8n1 - (other baud rates and parity can be used but needs to match the flow computer). Note: Typically, all other setup items can be left in their default state.

Resistor Is Built In To Factory Data Cable

REF: 2101240-WI

TOTALFLOW Products

ACTION

DOC TYPE

TITLE

DWG NO.

REV

SHEET

L15981

UD

uFLO w/ COMM TERM BD TO MDS TRANSNET 900 (RS-232)

2101644

AA

OF

You might also like