Professional Documents
Culture Documents
Factory-Made Wrought Buttwelding Fittings ASME B16.9-2001: Unit: U1 Textfile: B16P9$$$U1
Factory-Made Wrought Buttwelding Fittings ASME B16.9-2001: Unit: U1 Textfile: B16P9$$$U1
180 Deg Returns All Fittings Inside Diameter at End [Notes (1),(3), and (4)] Wall Thickness, t [Note (3)] 2 2 2 2 2 2 5 5 3 3 3 6 6 6 10 10 Overall Length of Caps, E CentertoCenter Dimension, O BacktoFace Dimension, K
(DN)
Center-to-End Dimensions of 90 Deg and 45 Deg Elbows and Tees, A, B, C, M Overall Length of Reducers and Lap Joint Stub Ends, F, H
Alignment of Ends, U
2 to 212 3 to 312 4 5 to 8 10 to 18 20 to 24 26 to 30 37 to 48 +1.60.8 +1.6 +1.6 +2.41.6 +4.03.2 +6.44.8 +6.44.8 +6.44.8 Not Less Than 87.5% of Nominal Thickness Lap Joint Stub Ends 0.8 1.6 1.6 1.6 3.2 4.8 4.8 4.8 2 2 2 2 2 2 3 5 6 6 6 6 10 10 ... ...
6 6 6 6 6 6 ... ...
7
(DN) +01 +01 +01 +01 +02 +02 ... ... +01 +01 +02 +02 +02 +02 ... ... See Table 10 For Limiting Dimensions +1.60 +1.60 +1.60 +1.60 +3.20 +3.20 ... ... Fillet Radius of Lap, R Lap Thickness Outside Diameter of Barrel
Off Angle, Q 1 2 2 3 4 5 5 5
Off Plane, P 2 4 5 6 10 10 13 19
2 to 212 3 to 312 4 5 to 8 10 to 18 20 to 24 26 to 30 37 to 48
GENERAL NOTES: (a) For reference, see Table 2 Illustration beginning on page 6. (b) All dimensions are in millimeters. (c) Tolerances are equal plus and minus except as noted. NOTES: (1) Out-of-round is the sum of absolute values of plus and minus tolerances. (2) This tolerance may not apply in localized areas of formed fittings where increased wall thickness is required to meet design requirements of para. 2.2. (3) The inside diameter and the nominal wall thicknesses at ends are to be specified by the purchaser. (4) Unless otherwise specified by the purchaser, these tolerances apply to the nominal inside diameter, which equals the difference between the nominal outside diameter and twice the nominal wall thickness.
ASME B16.9-2001