Professional Documents
Culture Documents
Memory Erasing Procedure: Transfer Controller Pin Assignment
Memory Erasing Procedure: Transfer Controller Pin Assignment
5. Keeping the connector of the transfer controller connected, set the short harness from the back of the connector as illustrated. 6. Turn ON the gnition, wait for 2 seconds, and turn OFF the ignition after confirming the relay sound. 7. Disconnect the short harness, turn ON the ignition again, and confirm the "Check 4WD" lamp in the meter panel is OFF. 8. Before erasing the memory, check that the circuit of the T/F actuator position detection harness, etc. for t are normal.
Axle Dummy
1_
IG N IND
LS2
1
TMt TM2 TM3
8'
+B
7
4L Out 4WD Axle Out M2 Axle M1 T/F M1 T/F M2 GND
Op SW Veo
Spd
LS1
ENG. Rev,
LS3
LS4
N SW
GND
4H IND
20
19
18
17
16
A
15
14
13
12
11
14
13
12
11
10