Professional Documents
Culture Documents
PS Warning Light Does Not Come ON: Wiring Diagram
PS Warning Light Does Not Come ON: Wiring Diagram
CANH
17 F1
2 A66
CANH
CANL
18 F1
3 A66
CANL
IG1 Relay ECU IG No. 2 From Battery Main Body ECU (Instrument Panel J/B) 5 3 9 A66 IG
3 IG1D E7
5 A66
PGND
B139366E01
INSPECTION PROCEDURE
INSPECT CAN COMMUNICATION SYSTEM (a) Using the intelligent tester, check for DTCs and confirm that there are no problems in the CAN communication system. OK: DTCs are not output.
PS
PS59
NG OK
INSPECT COMBINATION METER ASSEMBLY (a) Connect the intelligent tester (with CAN VIM ) to the DLC3. (b) Turn the power switch on (IG). (c) Perform the ACTIVE TEST according to the display on the tester.
COMBINATION METER:
Tester Display EPS INDIC Test Part PS indicator light OFF/ON Control Range ON / OFF Diagnostic Note -
OK: The PS warning light comes on or goes off according to the tester operation. NOTICE: If replacing the power steering ECU assembly, initialize the rotation angle sensor value and calibrate the torque sensor zero point (See page PS13). NG OK REPLACE POWER STEERING ECU ASSEMBLY (See page PS-68) REPLACE COMBINATION METER ASSEMBLY (See page ME-64)
PS