Professional Documents
Culture Documents
3100 Bus Starting October, 2009 - Electrical Circuit Diagrams s08342
3100 Bus Starting October, 2009 - Electrical Circuit Diagrams s08342
3100 Bus Starting October, 2009 - Electrical Circuit Diagrams s08342
S08342
Copyright 02/24/2010 International Truck and Engine Corporation
Table of Contents
SAFETY INFORMATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1 3100 BUS CIRCUIT DIAGRAMS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
S08342
ii
S08342
SAFETY INFORMATION
IMPORTANT Read the following before starting the service procedure.
The information contained in this International Service Manual Section was current at the time of printing
and is subject to change without notice or liability.
You must follow your company safety procedures when you service or repair equipment. Be sure to understand
all of the procedures and instructions before you begin work on the unit.
International uses the following types of notations to give warning of possible safety problems and to give
information that will prevent damage to the equipment being serviced or repaired.
WARNING A warning indicates procedures that must be followed exactly. Personal injury
or possible death can occur if the procedure is not followed.
CAUTION A caution indicates procedures that must be followed exactly. If the procedure is not
followed, damage to equipment or components can occur.
NOTE A note indicates an operation, procedure or instruction that is important for correct service.
Some procedures require the use of special tools for safe and correct service. Failure to use these special
tools when required can cause injury to service personnel or damage to vehicle components.
This service manual section is intended for use by professional technicians, NOT a do-it-yourselfer. It is
written to inform these technicians of conditions that may occur on some vehicles, or to provide information
that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools,
safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT assume
that the service section applies to your vehicle. See your International Truck Dealer for information on whether
this service section applies to your vehicle.
S08342
S08342
Table of Contents
S08342
9.2.
9.3.
9.4.
9.5.
9.6.
9.7.
9.8.
9.9.
S08342
Figure 1
S08342
Figure 2
S08342
Figure 3
S08342
Figure 4
S08342
Figure 5
S08342
10
Figure 6
S08342
Figure 7
S08342
11
12
Figure 8
S08342
Figure 9
S08342
13
14
Figure 10
S08342
Figure 11
S08342
15
16
Figure 12
S08342
Figure 13
S08342
17
18
Figure 14
Battery
S08342
Figure 15
S08342
19
20
Figure 16
Fuse Block
S08342
Figure 17
Horn
S08342
21
22
Figure 18
Charging System
S08342
Figure 19
Cranking System
S08342
23
24
5. GAUGES (CHAPTER 5)
5.1. FUEL LEVEL, P. 1
Figure 20
Fuel Level
S08342
Figure 21
Low Oil Press./High Water Temp., Stop Engine, Engine, Brake Warnings
S08342
25
26
Figure 22
Water in Fuel
S08342
Figure 23
S08342
27
28
Figure 24
Air Dryer
S08342
Figure 25
S08342
29
30
Figure 26
S08342
Figure 27
S08342
31
32
Figure 28
S08342
Figure 29
Feed
S08342
33
34
Figure 30
S08342
Figure 31
S08342
35
36
Figure 32
S08342
Figure 33
Coolant Level
S08342
37
38
Figure 34
Exhaust System
S08342
9.7. GATEWAY, P. 7
Figure 35
Gateway
S08342
39
40
Figure 36
Instrument Cluster
S08342
Figure 37
Instrument Cluster
S08342
41
42
Figure 38
S08342
Figure 39
S08342
43
44
Figure 40
S08342
Figure 41
S08342
45
46
Figure 42
S08342
Figure 43
S08342
47
48
Figure 44
S08342
Figure 45
S08342
49
50
Figure 46
S08342
Figure 47
S08342
51
52
Figure 48
S08342
Figure 49
S08342
53
54
Figure 50
S08342
Figure 51
S08342
55
56
Figure 52
S08342