Professional Documents
Culture Documents
CC Amplifier (Emitter Follower) : Exp. No.: Date
CC Amplifier (Emitter Follower) : Exp. No.: Date
com
Exp. No.: Date:
www.jwjobs.net
S.No. 1. 2. 3. 4. 5.
CIRCUIT DIAGRAM:
+10V
RL 1.5K
VO
PROCEDURE:
1. Connect the circuit as shown in figure. 2. Apply the biasing voltage of 10 V. 3. Adjust the Signal generator voltage so as to get Vi =1V and measure Vs. 4. Vary the frequency of the signal generator from 100Hz to 1MHz, in steps and note down corresponding output voltage. 5. In the mid band range remove RL and note down the output which is VNL.
www.jntuworld.com
www.jntuworld.com
Exp. No.:
6. Plot the frequency response and determine the bandwidth. 7. Calculate the input and output impedance in the mid band range using
www.jwjobs.net
Date:
Ri =
Vi RS VS Vi
RO =
V NL V FL RL = VFL
8. Calculate the current gain(AI), voltage gain(AV) and power gain(AP) using
IO = Ii V IO = O = RO AI = AV = VO = Vi
Ii =
V s Vi = Rs
TABULATION : Vs=
S No. Frequency (Hz)
VNL =
Vi
(V)
Vo
(V)
Av =
Vo Vi
20 log Av
www.jntuworld.com
www.jntuworld.com
Exp. No.:
S No. Frequency (Hz)
www.jwjobs.net
Date:
Vi
(V)
Vo
(V)
Av =
Vo Vi
20 log Av
MODEL GRAPH:
3db 20 log Av
f1
f2
Bandwidth = f2 - f1 =
RESULTS:
Input impedance(Ri)
www.jntuworld.com