Professional Documents
Culture Documents
Shield Anchor Hex Bolt: Steel Yellow Zinc Plated
Shield Anchor Hex Bolt: Steel Yellow Zinc Plated
qxp
10/07/2007
13:39
Page 1
Uses:
Installation
1. Drill correct diameter hole to recommended depth. Clean hole thoroughly with a nylon brush. Remove debris by way of a vacuum pump, compressed air hand pump, etc. 2. Insert shield anchor nut end first into the hole until it is flush with the surface. 3. Insert correct size bolt through the fixture into the shield anchor and tighten.
Technical Information
Anchor/Hole Thread Embedment Fixture Clearance Centre Edge Rec. Tensile Rec. Shear Rec. Tightening mm Depth mm Hole mm Spacing mm Spacing mm Load kN Load kN Torque Nm 12 M6 50 7-8 120 80 3.3 2.1 6.5 14 M8 55 9 - 10 150 100 4.8 4.4 15 16 M10 65 11 - 12 180 120 6.2 6.1 27 20 M12 85 13 - 14 250 160 9.7 12.4 50 25 M16 125 17 - 18 290 190 21.3 27.6 120
10.02 Winzer Wrth Mtg NE H05 0080 / M02 0050 / C01 0233
H05 0080
M02 0050