Professional Documents
Culture Documents
Service Bulletin: Cab Back-Wall Trim Molding - CH Model Chassis
Service Bulletin: Cab Back-Wall Trim Molding - CH Model Chassis
Service Bulletin: Cab Back-Wall Trim Molding - CH Model Chassis
BULLETIN
NUMBER: DATE: MODEL: SB-642-003 5/24/02 CH
(Not applicable to Mack Trucks Australia) (Supersedes bulletin SB-642-003 dated 7/25/00)
3. Apply a generous bead of super glue gel (part No. 3760-2999 or equivalent), to the backside of the molding, approximately one inch from the outer edge. If the molding has been completely removed from the cab, apply additional adhesive to the center section.
REV
Super glue gel (part No. 3760-2999) is available through the MACK Parts System. Approximately 8 ounces of adhesive will be required.
This adhesive has a very short cure time (approximately 12 minutes). 4. After the adhesive has been applied, press the molding firmly in place against the back wall trim panel and hold for approximately 25 minutes or until the adhesive dries. The labor code and maximum labor allowance are as follows:
Labor code/allowance......................................... 642 1A 01 80 0.5 hr. Time to remove molding from cab back-wall trim panel, apply adhesive and reinstall molding. Does not include .2 hr. take charge time.
SB-642-003 Page 1 of 1
SERVICE PUBLICATIONS, ALLENTOWN, PA 18105 MACK TRUCKS, INC. 2002