Professional Documents
Culture Documents
LC-32SH130E LC-32SH130K LC-32SH340E: Service Manual
LC-32SH130E LC-32SH130K LC-32SH340E: Service Manual
LC-32SH130E LC-32SH130K LC-32SH340E: Service Manual
LC-32SH130K
LC-32SH340E
1st Edition
50mm
SERVICE MANUAL
40mm
DVB-T / DVB-C (HDTV), PAL B/G, I / SECAM B/G, D/K, L/L SYSTEM COLOUR TELEVISION
31.5mm
17MB60 CHASSIS
25mm
MODELS
20mm
LC-32SH130E
LC-32SH130K
LC-32SH340E
CONTENTS
TABLE OF CONTENTS........................................................................................................................ 2
ELECTRICAL SPECIFICATIONS .......................................................................................................7
IMPORTANT SERVICE SAFETY PRECAUTIONS................................................................................. 8
OPERATION MANUAL ........................................................................................................................... 11
DIMENSIONS ..................................................................................................................................... 17
INTRODUCTION................................................................................................................................... 18
CIRCUIT DESCRIPTIONS .................................................................................................................. 21
SERVICE MENU SETTINGS .......................................................................................................... 66
SOFTWARE UPDATE ............................................................................................................................ 71
HOTEL TV MODE...................................................................................................................................72
TROUBLESHOOTING................................................................................................................... 76
SCHEMATIC DIAGRAMS...................................................................................................................... 85
PRINTED WIRING BOARD.....................................................................................................................95
REPLACEMENT PARTS LIST ............................................................................................................97
SHARP CORPORATION
1
LC-32SH130E
LC-32SH130K
LC-32SH340E
TABLE OF CONTENTS
i
SPECIFICATIONS.............................................................................................. 7
ii
iii
TABLE
OF CONTENTS
iv
DIMENSIONS
.................................................................................................. 17
1.
2.
3.
4.
5.
18
INTRODUCTION......................................................................................................7
1.1.
1.2.
20 9
MB60 Placement of Blocks ..............................................................................
21 10
TUNER(TU102) ....................................................................................................
2.1.
2211
General description of Samsung DTOS403LH122X: ................................................
2.2.
2211
Features of DTOS403LH122X: ........................................................................
2.3.
2312
Pinning:..................................................................................................
24 13
SAW FILTER Audio Epcos K9656M(Z101)....................................................................
3.1.
Standard.................................................................................................
2413
3.2.
Features .................................................................................................
2413
3.3.
2413
Pin configuration.......................................................................................
3.4.
2514
Frequency response ...................................................................................
26 15
SAW FILTER Video Epcos K3958M(Z102)....................................................................
4.1.
Standard.................................................................................................
2615
4.2.
Features .................................................................................................
2615
4.3.
4.4.
5.2.
Features .................................................................................................
2817
5.3.
2918
Absolute Ratings .......................................................................................
2918
5.3.1. Electrical Characteristics .............................................................................
3019
5.3.2. Operating Specifications ..............................................................................
5.4.
6.
3120
Pinning...................................................................................................
32 21
AUDIO AMPLIFIER STAGE WITH TPA3113(U168)...............................................................
6.1.
3221
General Description ...................................................................................
6.2.
3221
Features .................................................................................................
LC-32SH130E
LC-32SH130K
LC-32SH340E
6.3.
32 22
Absolute Ratings .......................................................................................
32 22
6.3.1. Electrical Characteristics .............................................................................
33 22
6.3.2. Operating Specifications ..............................................................................
6.4.
7.
8.
9.
33 23
Pinning...................................................................................................
34 24
POWER STAGE .....................................................................................................
7.1.
7.2.
39 29
General Description ...................................................................................
8.2.
General Features.......................................................................................
39 29
8.3.
8.4.
44 35
Reset Circuit ............................................................................................
45 36
CI INTERFACE ......................................................................................................
9.1
9.2
11.2.
Features .................................................................................................
4753
11.3.
11.4.
Pinning...................................................................................................
4854
12.2.
52 58
13. NAND FLASH MEMORY - MX25L1005 (U158)....................................................................
13.1.
13.2.
5258
Features .................................................................................................
13.3.
5258
Absolute Maximum Ratings ...........................................................................
13.4.
5259
Pinning...................................................................................................
14.2.
Features ................................................................................................. 60
14.3.
3
Pinning...................................................................................................
61
Features ................................................................................................. 58
13.3.
13.4.
Pinning................................................................................................... 59
53 60
14. NAND FLASH MEMORY NAND512XXA2C (U162) ..............................................................
14.1.
5360
General Description ...................................................................................
14.2.
5360
Features .................................................................................................
14.3.
5461
Pinning...................................................................................................
55 62
15. USB2.0 to Fast Ethernet ASIX AX88X72A (U171) ............................................................
15.1.
15.2.
5562
Features .................................................................................................
15.3.
5663
Block Diagram ..........................................................................................
15.4.
5664
Pinning...................................................................................................
57 64
16. LM1117(U175, U180, U181)......................................................................................
16.1.
16.2.
5764
Features .................................................................................................
16.3.
5765
Applications.............................................................................................
16.4.
5765
Absolute Maximum Ratings ...........................................................................
16.5.
5765
Pinning...................................................................................................
58 66
17. MP2012 (U176) ....................................................................................................
17.1.
5866
General Description ...................................................................................
17.2.
5866
Features .................................................................................................
17.3.
5867
Pinning...................................................................................................
59 68
18. RTA8283A (U23, U173) ...........................................................................................
18.1.
18.2.
5968
Features .................................................................................................
18.3.
6069
Pinning...................................................................................................
61 70
19. MP1583 (U174) ....................................................................................................
19.1.
6170
General Description ...................................................................................
19.2.
6170
Features .................................................................................................
19.3.
6170
Pinning...................................................................................................
62 72
20. FDC642 .............................................................................................................
20.1.
6272
General Description ...................................................................................
20.2.
Features ................................................................................................. 72
20.3.
Pinning................................................................................................... 72
21. FDC604P............................................................................................................ 73
21.1.
19.1.
19.2.
Features ................................................................................................. 70
19.3.
Pinning................................................................................................... 70
LC-32SH130K
LC-32SH340E
20.2.
Features .................................................................................................6272
20.3.
Pinning...................................................................................................6272
6373
21. FDC604P............................................................................................................
21.1.
21.2.
Features .................................................................................................6373
21.3.
Pinning...................................................................................................6373
6474
22. CONNECTORS ......................................................................................................
22.1.
SCART (SC1).............................................................................................6474
22.2.
22.3.
LC-32SH130E26.3.
LC-32SH130K
LC-32SH340E26.4.
26.5.
26.6.
26.7.
26.8.
26.9.
IR Problem .............................................................................................. 89
84
26.10. No Signal Problem ..................................................................................... 95
LC-32SH130E
LC-32SH130K
LC-32SH340E
LC-32LE210
LC-32LE220
ELECTRICAL
ELECTRICALSPECIFICATIONS
SPECIFICATIONS
Specifications
Speci
cations
Speci
cations
Speci
cations
TV BROADCASTING
TVBROADCASTING
BROADCASTING
Item
TV
Digital
Reception
(DVB-C)
Digital
Reception
(DVB-C)
Digital
Reception
(DVB-C)
Transmission
Standards:
Transmission
Standards:
24 LCD
COLOUR
Model:
32 LCD COLOUR TV, Model:
Transmission
Standards:
LCD
COLOUR
TV,TV,
Model:
LC-24LE210E,DVB-C,
LC-32LE210E,
LC-32LE220E,
MPEG2,
DVB-C,
MPEG4
DVB-C,
MPEG2,
DVB-C,
MPEG4
Only
for
LC32SH130E
- LC-32SH340E
DVB-C,
MPEG2,
DVB-C,
MPEG4
LC-32LE210E,
LC-32LB220E,
LC-32LE220E,
LC-32LS220E.
Digital Reception
(DVB-C)
LC-24LE220E
LC-32LB220E,
LC-32LS220E
DEMODULATION
i. DEMODULATION
i. i.
DEMODULATION
Standards:
32 TFT
LCD TFT
LED LCD
TVTransmission
24"
BLACK
LED TV
32 BLACK TFT LCD LED TV
-Symbolrate:
4.0
Msymbols/s
to7.2
7.2
Msymbols/s
-Symbolrate:
4.04.0
Msymbols/s
toto7.2
Msymbols/s
-Symbolrate:
Msymbols/s
Msymbols/s
DVB-C,
DVB-C, MPEG4
6.220.800 dots (1.920
x 1.080 MPEG2,
pixels)
Modulation:
16-QAM
,
32-QAM
,64-QAM,
128-QAM
- Modulation:
16-QAM
,
32-QAM
,64-QAM,
- Modulation:
16-QAM , 32-QAM ,64-QAM,128-QAM
128-QAM
i.3.58/NTSC
DEMODULATION
PAL/SECAM/NTSC
4.43/PAL 60
and
256-QAM
andand
256-QAM
256-QAM
-Symbolrate: 4.0 Msymbols/s to 7.2 Msymbols/s
CCIR (B/G, I, D/K, L/L)
VIDEO
ii. VIDEO
ii.ii.VIDEO
- Modulation:
16-QAM
, 32-QAM ,64-QAM, 128-QAM
DVB-T (2K/8K OFDM)(H.264),
DVB-C
(Only Lx220)
- All
MPEG2
MP@ML
formats
with
up-conversion
and
MPEG2
MP@ML
formats
with
up-conversion
and
- All- All
MPEG2
MP@ML
formats
with
up-conversion
and
and 256-QAM
ltering
to
CCIR601
format.
E2E69 ch, F2F10
ch,
I21I69
ch,
IR
AIR
J
ch
(Digital: IR A chE69 ch)
ltering
CCIR601
format.
ltering
to to
CCIR601
format.
ii. VIDEO
-CVBS
analogue
output
Hyper-band, S1S41
ch analogue
-CVBS
output
-CVBS
analogue
output
- All MPEG2 MP@ML formats with up-conversion and
iii.
AUDIO
Auto Preset 999 ch:
non-Nordic
/
9999
ch:
Nordic
(ATV: 99 ch), Auto Label, Auto Sort
AUDIOto CCIR601 format.
iii. iii.
AUDIO
ltering
-All
MPEG1
Layer
1
and
2modes
modes
NICAM/A2
MPEG1
Layer
1output
and
-All-All
MPEG1
Layer
1 and
2 2modes
-CVBS
analogue
-Samplingfrequencies
frequenciessupported
supportedare
are32,
32,44.1
44.1 &4848
H: 176, V: 176 -Sampling
-Sampling
frequencies supported
are 32,
44.1 &&48
iii. AUDIO
kHz
10 W x 2
kHz
kHz
-All MPEG1 Layer 1 and 2 modes
(30 mm
(25
mmxx100
100mm)
mm)x x2 2
(30 mm x 100 mm) x 2
-Sampling frequencies supported are 32, 44.1 & 48
UHF/VHF 75 Din type (Analogue & Digital)
kHz
PAL/SECAM
B/G D/K
KD/K
I/IKL/L
PAL/SECAM
B/GD/K
KI/II/IL/L
L/L
PAL/SECAM
SpeciB/G
cations
RECEIVING
CHANNELS
RECEIVING
CHANNELS
RECEIVING
CHANNELS
TV Panel
BROADCASTING
LCD
VHF(BAND
(BAND
I/III)
VHF VHF
(BAND
I/III) I/III)
PAL/SECAM
B/G D/K K I/I L/L
Resolution
UHF(BAND
(BAND
UHF UHF
(BAND
U) U)U)
RECEIVING
CHANNELS
Video Colour System
HYPERBAND
HYPERBAND
HYPERBAND
VHF (BAND
I/III)
TV Standard
Analogue
NUMBER
OFPRESET
PRESETCHANNELS
CHANNELS
NUMBER
PRESET
NUMBER
OF
UHFOF
(BAND
U) CHANNELS
Digital
1000
TV
10001000
HYPERBAND
VHF/UHF
CHANNEL
INDICATOR
FuncCHANNEL
INDICATOR
CHANNEL
INDICATOR
Receiving
ChannelCHANNELS
NUMBER
OF
PRESET
CATV
tions
OnScreen
ScreenDisplay
Display
On
On Screen
1000 Display
TV-Tuning System
RFAERIAL
AERIALINPUT
INPUT
RF
RF AERIAL
INPUT
CHANNEL
INDICATOR
STEREO
/ BILINGUAL
75
Ohm
(unbalanced)
75
Ohm
(unbalanced)
75 Ohm
(unbalanced)
On
Screen
Viewing
anglesDisplay
OPERATINGVOLTAGE
VOLTAGE
OPERATING
OPERATING
VOLTAGE
RF AERIAL
INPUT
Audio
Amplifier
220-240V
AC,
50Hz.
220-240V
AC,
50Hz.
Speaker
75 Ohm
(unbalanced)
220-240V
AC, 50Hz.
AUDIO
AUDIO
TV Antenna
OPERATING
VOLTAGE
AUDIO
German+ +Nicam
NicamStereo
Stereo
German
220-240V
AC,
50Hz.
SERVICE
3.5 mm jack
German
+ Nicam
Stereo
AUDIOOUTPUT
OUTPUTPOWER
POWER(W
(WRMS.
) (10%THD)
THD)
AUDIO
) (10%
SCART
SCART (AV input, RGB input, TV output, Y/C input)
AUDIOAUDIO
OUTPUT
POWER (WRMS.)RMS.
(10% THD)
x6 6
22
x
INPUTStereo
VGA (D-Sub 15pin), 3.5mm jack
Nicam
2 x 6 German +PC
POWERCONSUMPTION
CONSUMPTION(W)
(W)
POWER
AUDIO
OUTPUT
POWER
(W
)
(10%
THD)
COMPONENTS
COMPONENT
IN: Y/PB(CB)/PR(CR), RCA (AUDIO R/L)
RMS.
POWER
CONSUMPTION
(W)
150WW(max)
(max)
150
2
x
6
HDMI1
HDMI,
3.5mm
jack
150 W<(max)
0,5WW(Standby)
(Standby)
< POWER
0,5
HDMI2
HDMI,
3.5mm
jack
CONSUMPTION (W)
< 0,5 W
(Standby)
PANEL
Terminals
PANEL
150 W (max)
HDMI3
HDMI, 3.5mm jack
PANEL16:9 display,
32(80
(80cm)
cm)Screen
ScreenSize
Size
16:9
display,
32
< 0,5
W (Standby)
AV
RCA connector (AV input)
16:9 display,
32 (80 (mm)
cm) Screen Size
DIMENSIONS
DIMENSIONS
(mm)
PANEL MEDIA
PLAYER/ TIME-SHIFT/
USB 2.0 HOST (A type)
DIMENSIONS
(mm)
DxLxH(With
(With
foot):
212x x776
776x x567
567
USB
REC212
DxLxH
foot):
16:9 display,
32
(80 cm)
Screen Size
DxLxH
(With
foot):
212AUDIO
x 776OUTPUT
x 567
Weight(Kg):
(Kg):
12,30
DIGITAL
RCA S/PDIF digital audio output.
Weight
12,30
DIMENSIONS (mm)
Weight
(Kg):(Without
12,30
DxLxH
(Without
foot):94
94x x776
776x x524
524 EN50221, R206001, CI+ speci cation (Only Lx220)
C. I. (Common
Interface)
DxLxH
foot):
DxLxH (With foot): 212 x 776 x 567
DxLxH
(Without
foot):
94 x 776 x 524
Weight
(Kg):
11,60
Headphones
3.5 mm jack (Audio output)
Weight
11,60
Weight(Kg):
(Kg):
12,30
Weight (Kg): 11,60
Czech, Danish, Dutch, English, Estonian, Finnish, French, German, Greek, Hungarian, Italian,
DxLxH (Without foot): 94 x 776 x 524 Latvian, Lithuanian, Norwegian, Polish, Portuguese, Russian, Slovak, Slovene, Spanish,
OSD language
Swedish, Turkish, Ukrainian, Byelorussian, Romanian.
Weight (Kg): 11,60
Power Requirement
AC 220240 V, 50 Hz
85 W (0.25
(0.25 W
30W
W(Standby)
Standby)
Weight
8,5 Kg
9,86 Kg
4,9
Kg(Without
(Withoutstand),
stand),
Kg(With
(Withstand)
stand)
MHEG-5ENGINE
ENGINEcompliant
compliant
with
ISO/IEC13522-5
13522-5UK
UKengine
enginePro
Pro
Operating TemperatureMHEG-5
0 C to +40
C ISO/IEC
with
lele1 1
Objectcarousel
carouselsupport
supportcompliant
compliantwith
withISO/IEC
ISO/IEC135818-6
135818-6and
andUK
UKDTT
DTTpro
prole forforUK
UK
Object
MHEG-5
ENGINE compliant
with ISO/IEC
13522-5 UK engine
Pro
le 1 le
Frequency
range:
474-850
MHz
for
UK
models
Environmental Specifications
Object carousel
support
compliant
ISO/IEC
and
UK DTT
pro
for UK
Frequency
range:with
474-850
MHz135818-6
for UK models
MHEG-5
ENGINE
compliant
with
ISO/IEC
13522-5
UK engine
Pro
le le
1
170-862
MHz
for
EU
models
170-862
MHz
for
EU
models
Object
carousel
support
compliant
with
ISO/IEC
135818-6
and
UK
DTT
pro
le
for UK
Frequency range: 474-850 MHz for UK models
Digital
Digital
*1 Measured according to IEC 62087 Ed. 2.
32
Transmission
standard:
DVB-T.
MPEG-2,
MPEG-4
Transmission
standard:
DVB-T.
MPEG-2,
MPEG-4
Reception
*2 For
further
about the Energy Save function,
Frequency
range:
MHz
for information
UK models
Reception
170-862
MHz474-850
for EU
models
Demodulation:
with
2K/8K
FFTmode
mode
Digital
*1 On-Mode (W) (HOME MODE)
63COFDM
WCOFDM
please
seeFFT
related
pages in this operation manual.
Demodulation:
with
2K/8K
Transmission
standard:
DVB-T.
MPEG-2,
MPEG-4
170-862
MHz
for
EU
models
*3 Measured according to IEC 62301 Ed. 1.
Reception
*2(DVB-T)
Energy-Save-Mode
(W)
ECO
48
W all DVB
Digital
FEC:
modes
FEC:
all DVB
modes
*42K/8K
Measured
according
to IEC 62301 Ed. 1.
Demodulation:
with
FFT
mode
TransmissionCOFDM
standard:
DVB-T.
MPEG-2,
MPEG-4
*3 Standby-Mode
0.25
W
Reception (W)
Video:MP@ML,
MP@ML,PAL,
4:3/16:9
*5PAL,
Annual
energy consumption is calculated on the basis
Video:
4:3/16:9
Demodulation:
COFDM
with
2K/8K
FFT
mode
*4 Off Mode (W)
0.18
W
FEC: all DVB modes
of the On-Mode (HOME MODE) power consumption,
Audio: MPEG
LayerI&II
I&II32/44.148kHz.
32/44.148kHz.
*5 Annual Energy Consumption (kWh)
92 kWh
Audio:
Layer
FEC:
allPAL,
DVBwatching
modesTV 4 hours a day, 365 days a year.
Video:MPEG
MP@ML,
4:3/16:9
*6 Annual Energy Consumption
ECO
71 kWh
*6 Annual energy consumption is calculated on the basis of
Video:Layer
MP@ML,
PAL,
4:3/16:9
Energy-Save-Mode (kWh)
Audio: MPEG
I&II 32/44.148kHz.
the Energy-Save-Mode power consumption, watching TV
English - 37
- 437
- a day, 365 days a year.
English
hours
Audio: MPEG Layer I&II 32/44.148kHz.
Englishenvironments
- 37 Cautions regarding
use in high and low temperature
As a part
of our policy
of 10:38:37
continuous imA01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd
03.06.201110:38:37
English - 37 A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd
3737
03.06.2011
provement, SHARP reserves the right to
When the unit is used in a low temperature space (e.g. room, office), the
make37 design and
specifi
cation changes
03.06.2011
10:38:37
pictureA01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd
may leave trails or appear slightly delayed. This is not a malfuncA01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd
37
03.06.2011 10:38:37
for product
improvement
without prior
tion, and the unit will recover when the temperature returns to normal.
notice. The performance specification fig Do not leave the unit in a hot or cold location. Also, do not leave the
ures indicated are nominal values of prounit in a location exposed to direct sunlight or near a heater, as this may
duction units. There may be some deviacause the cabinet to deform and the LCD panel to malfunction. Storage
tions from these values in individual units.
temperature: 20C to +60C.
2
7
LC-32SH130E
LC-32SH130K
LC-32SH340E
Service work should be performed only by qualified service technicians who are thoroughly familiar with all
safety checks and the servicing guidelines which follow:
WARNING
Plug the AC cord directly into a 220~240 volt AC outlet. (Do not use an isolation transformer for this test).
Using two clip leads, connect a 1.5k ohm, 10 watt resistor paralleled by a 0.15F capacitor in series with all exposed metal
cabinet parts and a known earth ground, such as electrical conduit or electrical ground connected to an earth ground.
A true RMS reading multimeter should be used for this test, especially where the equipment uses a switch mode
power supply which may result in very non-sinusoidal leakage current.
Connect the resistor connection to all exposed metal parts having a return to the chassis (antenna, metal cabinet,
screw heads, knobs and control shafts, escutcheon, etc.) and measure the AC voltage drop across the resistor.
All checks must be repeated with the AC cord plug connection reversed. (If necessary, a nonpolarized adaptor plug must
be used only for the purpose of completing these checks.)
Any reading of 1.05V peak (this corresponds to 0.7 mA. peak AC.) or more is excessive and indicates a potential shock
hazard which must be corrected before returning the monitor to the owner.
DVM
AC SCALE
1.5k ohm
10W
0.15 F
TEST PROBE
TO EXPOSED
METAL PARTS
CONNECT TO
KNOWN EARTH
GROUND
SAFETY NOTICE
Many electrical and mechanical parts in LCD television have special safety-related characteristics.
These characteristics are often not evident from visual inspection, nor can protection afforded by them be necessarily
increased by using replacement components rated for higher voltage, wattage, etc.
Replacement parts which have these special safety characteristics are identified in this manual; electrical components
having such features are identified by ! .
For continued protection, replacement parts must be identical to those used in the original circuit.
The use of a substitute replacement parts which do not have the same safety characteristics as the factory recommended
replacement parts shown in this service manual, may create shock, fire or other hazards.
LC-32SH130E
LC-32SH130K
LC-32SH340E
ALL PWB of this model employs lead-free solder. The LF symbol indicates lead-free solder, and is attached on the
PWBs and service manuals. The alphabetical character following LF shows the type of lead-free solder.
Example:
e:
LFa
Indicates lead-free solder of tin, silver and copper.
LFn
Sn-Ag-Ni
When fixing the PWB soldered with the lead-free solder, apply lead-free wire solder. Repairing with conventional lead
wire solder may cause damage or accident due to cracks.
As the melting point of lead-free solder (Sn-Ag-Cu) is higher than the lead wire solder by 40C, we recommend you to
use a dedicated soldering bit, if you are not familiar with how to obtain lead-free wire solder or soldering bit, contact our
service station or service branch in your area.
3 Soldering
As the melting point of lead-free solder (Sn-Ag-Cu) is about 220C which is higher than the conventional lead solder by
40C, and as it has poor solder wettability, you may be apt to keep the soldering bit in contact with the PWB for extended
period of time. However, Since the land may be peeled off or the maximum heat-resistance temperature of parts may be
exceeded, remove the bit from the PWB as soon as you confirm the steady soldering condition.
Lead-free solder contains more tin, and the end of the soldering bit may be easily corroded. Make sure to turn on and
off the power of the bit as required.
If a different type of solder stays on the tip of the soldering bit, it is alloyed with lead-free solder. Clean the bit after every
use of it.
When the tip of the soldering bit is blackened during use, file it with steel wool or fine sandpaper.
Be careful when replacing parts with polarity indication on the PWB silk.
Lead-free wire solder for servicing.
LC-32SH130E
LC-32SH130K
LC-32SH340E
10
English - 39 -
LC-32SH130E
LC-32SH130K
LC-32SH340E
OPERATION MANUAL
Remote Control Buttons
1. Standby
2. Image size / Zooms videos (in Media Browser
video mode)
3. Sleep Timer
4. Mono / Stereo - Dual I-II / Currrent Language (*)
(in DVB channels)
SLEEP
SCREEN
FAV
LANG.
PRESETS
EPG
11. No function
SWAP
SOURCE
DISP.
SEARCH
MODE
INFO
CH
English - 8 A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 8
11
03.06.2011 10:38:20
LC-32SH130E
LC-32SH130K
LC-32SH340E
Control Buttons
1. Standby/On button
2. TV/AV button
3. Programme Up/Down buttons
4. Volume Up/Down buttons
Note: Press
and
buttons at the same time to view
main menu.
SPDIF
VGA
Coax.OUT
SCART
A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 9
12
03.06.2011 10:38:21
LC-32SH130E
LC-32SH130K
LC-32SH340E
Power Connection
IMPORTANT: The TV set is designed to operate on 220-240V AC, 50Hz.
After unpacking, allow the TV set to reach the ambient room temperature before you connect the set to the
mains. Plug the power cable to the mains socket outlet.
Aerial Connection
Connect the aerial ,cable TV plug to the AERIAL INPUT socket located at the rear of the TV.
SPDIF
Aerial or Cable
VGA
Coax.OUT
SCART
English - 10 A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 10
13
03.06.2011 10:38:22
LC-32SH130E
LC-32SH130K
LC-32SH340E
USB Connection
SIDE VIEW
USB
5Vdc
Max:500mA
USB MEMORY
English - 11 -
A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 11
14
03.06.2011 10:38:24
LC-32SH130E
LC-32SH130K
LC-32SH340E
HDMI
Scart Cable
(not supplied)
HDMI Cable
(not supplied)
Scart sockets
HDMI
inputs
SPDIF
VGA
HDMI Cable
(not supplied)
Coax.OUT
SCART
External device
DVD Player
YPbPr
Connection Cable
(supplied)
DVD Player
English - 12 A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 12
15
03.06.2011 10:38:24
LC-32SH130E
LC-32SH130K
LC-32SH340E
Switching On/Off
To Switch the TV On
PC Input
(back)
Or
PC Audio Cable
(Not supplied)
Side AV Input
or a numeric
Camera
Switch the
button on the bottom right hand
side under the screen to position 2 as illustrated,
to isolate the TV from the mains, the LED will
go out.
Inserting Batteries
Remove the battery cover located on the back of
the handset by gently pulling backwards from the
indicated part.
English - 13 -
A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 13
16
03.06.2011 10:38:25
LC-32SH130E
LC-32SH130K
LC-32SH340E
DIMENSIONS
Dimensional Drawings
Specications
TV BROADCASTING
PAL/SECAM B/G D/K K I/I L/L
RECEIVING CHANNELS
VHF (BAND I/III)
UHF (BAND U)
HYPERBAND
NUMBER OF PRESET CHANNELS
1000
CHANNEL INDICATOR
On Screen Display
RF AERIAL INPUT
75 Ohm (unbalanced)
OPERATING VOLTAGE
220-240V AC, 50Hz.
AUDIO
German + Nicam Stereo
AUDIO OUTPUT POWER (WRMS.) (10% THD)
2x6
English - 38 -
Digital
A01_MB60_[GB]_1910UK_IDTV_TC_PVR_NICKEL16_32883W_YPBPR_ROCKER_10072419_50185320.indd 38
17
Reception
170-862 MH
03.06.2011 10:38:37
Transmission standard
Demodulation: COFD
FEC: all
LC-32SH130E
LC-32SH130K
LC-32SH340E
1. INTRODUCTION
17MB60 mainboard is driven by MStar SOC. This IC is capable of handling Video and audio processing,
Scaling-Display processing, 3D comb filter, OSD and text processing, LVDS transmitting, channel and
MPEG2/4 decoding, integrated DVB-T/C demodulator and media center functionality.
TV supports
PAL, SECAM, NTSC color standards and multiple transmission standards as B/G, D/K, I/I,
and L/L including German and NICAM stereo. Also DVB T, DVB-C are supported internal demodulators of
MStar IC and DVB-T2 is supported with external demodulator.
Sound system output is supplying max. 2x2,5W ( less 10%THD at max output) with 4 speakers or 2x6W
for stereo 8 speakers.
Supported peripherals are:
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
18
LC-32SH130E
LC-32SH130K
LC-32SH340E
19
20
DVD
Keyboard
External
Power Connector
CI Connector
LVDS
RAM
DDR2
Connectors
(U162)
Nand
Flash
DDR2
Main IC (U157)
Filter
Saw
Etherne
t IC
SPI
Ethernet
Connector
or
HDMI
Connectors
Tuner(TU102)
Keypad
SPDIF
VGA
YPbPr
HP
Connector
SCART
SAV
Inv.
Led
Speake
LC-32SH130E
LC-32SH130K
LC-32SH340E
LC-32SH130E
LC-32SH130K
LC-32SH340E
CIRCUIT DESCRIPTIONS
2. TUNER(TU102)
A horizontal mounted and Digital Half-NIM tuner is used in the product, which covers 3 Bands(From 48MHz
to 862MHz for COFDM, from 45.25MHz to 863.25MHz for CCIR CH). The tuning is available through the
digitally controlled I2C bus (PLL). Below you will find info about the tuner.
In active antenna option, the following circuit are used. ANT_CTRL pin is controlled by microcontroller. If
ANT_CTRL is low, ANT_PWR will be low. If ANT_CTRL is high, ANT_PWR will be logic high.
OVER_CUR_DETECT pin is a monitor for short circuit in antenna. OVER_CUR_DETECT is low,
ANT_CTRL will be low, so ANT_PWR will be low. Finally, short circuit protection is done by circuits and
microcontroller.
21
LC-32SH130E
LC-32SH130K
LC-32SH340E
Receiving System: This TUNER is designed to cover the air channels in VHF and UHF, compliant
with DVB-T standard. and It covers all Analog channels from 48.25MHz to 863.25MHz
Intermediate Frequency:
Input Impedance
: 75, Unbalanced
Tuning System
22
LC-32SH130E
LC-32SH130K
LC-32SH340E
2.3.Pinning:
Pin no.
Terminal Name
Pin Description
Ant Power
B+
RF AGC
CL
DA
BP
BT(T.P)
AS
IF AGC
10
IF OUT +
11
IF OUT -
12
AIF Output
23
LC-32SH130E
LC-32SH130K
LC-32SH340E
B/G
D/K
I
L/L
3.2.Features
3.3.Pin configuration
1 Input
2 Switching input
3 Chip carrier - ground
4 Output
5 Output
24
LC-32SH130E
LC-32SH130K
LC-32SH340E
3.4.Frequency response
25
LC-32SH130E
LC-32SH130K
LC-32SH340E
B/G
D/K
I
L/L
4.2.Features
4.3.Pin configuration:
1 Input
2 Input - ground
3 Chip - carrier ground
4 Output
5 Output
26
LC-32SH130E
LC-32SH130K
LC-32SH340E
4.4.Frequency response
27
LC-32SH130E
LC-32SH130K
LC-32SH340E
CMOS Technology
High Efficiency 85%
High PSRR 70dB at 217Hz
Differential OP-amp Input
AZAD2102B provides Vibration-Spectrum Modulation clock for reduce EMI
Provide Mute function(set Mute_B to GND will go into Mute status)
For the input stage AZAD2102B built-in a 10Kohm resistors (Gain setting=29.5dB)
Maximum Battery Life and Minimum Heat
Efficiency With an 8- Speaker:
3.5 mA Quiescent Current
Output Power at 10% THD
2.85Watts at AVdd=DVdd=5.0Volt, Rload=4
1.45Watts at AVdd=DVdd=3.6Volt, Rload=4
0.30Watts at AVdd=DVdd=3.0Volt, Rload=4
1.75Watts at AVdd=DVdd=5.5Volt, Rload=8
0.87Watts at AVdd=DVdd=3.6Volt, Rload=8
0.41Watts at AVdd=DVdd=3.0Volt, Rload=8
Eliminate Power on and Power-off Pop noise
A Fewer External Components
Optimized PWM Output Stage Eliminates LC Output Filter
Internally generate 290 kHz Switching Frequency to eliminate Capacitor and Resistor
Improve PSRR (70 dB) and Wide Supply Voltage (3.0 V to 5.5 V)
Fully Differential Design Reduces RF Rectification
This chip has been built-in a very strong ESD protection.
System level ESD 4KV (IEC 61000-4-2 ESD Contact Level)
Wafer Chip Scale Package (WCSP)
TSSOP Package with Exposed Pad
28
LC-32SH130E
LC-32SH130K
LC-32SH340E
5.3.Absolute Ratings
5.3.1.Electrical Characteristics
29
LC-32SH130E
LC-32SH130K
LC-32SH340E
5.3.2.Operating Specifications
30
LC-32SH130E
LC-32SH130K
LC-32SH340E
5.4.Pinning
31
LC-32SH130E
LC-32SH130K
LC-32SH340E
6.3.Absolute Ratings
6.3.1.Electrical Characteristics
6.3.2.Operating Specifications
32
LC-32SH130E
LC-32SH130K
LC-32SH340E
6.3.2.Operating Specifications
6.4.Pinning
33
LC-32SH130E
LC-32SH130K
LC-32SH340E
7. POWER STAGE
The DC voltages required at various parts of the chassis and panel are provided by a main power supply
unit. MB60 chassis can operate with IPS60, IPS16, IPS17, PW26, PW27 as main power supply and also with
12V adaptor.
CN706 is used for IPS60, IPS16 and IPS17 and CN1 is used for PW26 and PW27.
JK9 is used for the adapter option and also CN705 inverter socket or DB32 chassis with CN706 is used to
supply backlight.
The power supplies generate 18V, 12V, 5V, 3,3V and 12V, 5V, standby mode DC voltages. Power stage
which is on-chassis generates 5V, 3V3 stand by voltage and 12V, 8V, 5V, 3V3, 2.5V, 1,8V and 1,2V supplies
for other different parts of the chassis. Chassis block diagram is indicated below.
34
LC-32SH130E
LC-32SH130K
LC-32SH340E
35
LC-32SH130E
LC-32SH130K
LC-32SH340E
36
LC-32SH130E
LC-32SH130K
LC-32SH340E
12Vcc1
+1270
Fuse
12Vcc1
@3138mA = 1270mA+1408mA+460mA
P ch
Mosfet
FDC642
12Vcc2
@1270mA = 1050mA+220mA
DC/DC
12Vcc1
+1408mA
MP1583
SO-8
3.3Vcc
+240mA
5Vstby
+774mA
5Vstby
+2682mA
Option5 Vcc
5Vcc
+510mA
+2682mA
12Vcc1
+460mA
3.3Vstby
+1269mA
N ch
Mosfet
NTGS3446
@ 240mA
MP2012
1.5A
ADJ QFN6
1.8V
@ 1135mA
DC/DC
DC/DC
MP1484
3A
ADJ SO-8
2.5V
DC/DC
@2703mA=21mA+2682
3.3Vcc
N ch
Mosfet
NTGS3446
LDO
LM1117
DPAK
12Vcc2
3.3Vstby
220mA
@1339mA = 70mA+1269mA
MP1484
3A
ADJ SO-8
1.26V
@ 1680mA
3.3Vcc
+1269mA = 255mA+240mA+774mA
24Vcc @1500mA
12Vcc2 @2170mA = 1950mA+220mA
5Vcc @1482mA
3.3Vcc @1269mA = 255mA+240mA+774mA
5Vstby @21mA
3.3Vstby @70mA
3.3Vcc
+240mA
LDO
LM1117
DPAK
2.5V
@ 240mA
DC/DC
3.3Vcc
+774mA
Option5 Vcc
+510mA
MP2012
1.5A
ADJ QFN6
1.8V
@ 1135mA
DC/DC
12Vcc2
220mA
37
MP1484
3A
ADJ SO-8
1.26V
@ 1680mA
LC-32SH130E
LC-32SH130K
LC-32SH340E
24Vcc 1500mA
12Vcc2 @2170mA = 1950mA+220mA
5Vcc @1482mA
3.3Vcc @1269mA = 255mA+240mA+774mA
4.2V (Low Power Stby) @91mA = 70mA +21mA
3.3Vcc
+240mA
LDO
LM1117
DPAK
2.5V
@ 240mA
DC/DC
3.3Vcc
+774mA
Option5 Vcc
+510mA
MP2012
1.5A
ADJ QFN6
1.8V
@ 1135mA
DC/DC
4.2V
4.2Vstby
LM1117
Or
2x RS1002
JUMPER
JUMPER
12Vcc2
220mA
3.3Vstby
MP1484
3A
ADJ SO-8
1.26V
@ 1680mA
@70mA
5Vstby
@21mA
5Vstby @21mA
3.3Vcc
+240mA
12Vcc1
+2170mA
P ch
Mosfet
FDC642
+460mA
MP1484
3A
ADJ SO-8
12Vcc2
3.3Vcc
@2170mA = 1950mA+220mA
+774mA
Option5 Vcc
+510mA
3.3Vstby
+1269mA
@ 240mA
MP2012
1.5A
ADJ QFN6
1.8V
@ 1135mA
DC/DC
3.3Vstby
@1339mA = 70mA+1269mA
12Vcc2
N ch
Mosfet
NTGS3446
2.5V
DC/DC
DC/DC
12Vcc1
LDO
LM1117
DPAK
220mA
3.3Vcc
+1269mA = 255mA+240mA+774mA
38
MP1484
3A
ADJ SO-8
1.26V
@ 1680mA
LC-32SH130E
LC-32SH130K
LC-32SH340E
8. MICROCONTROLLER MSTAR(U157)
8.1.General Description
The MSD9WB7PX-2 integrates DTV/multi-media all-purpose AV decoder, DVB-T demodulator, VIF
demodulator, and Sound/Video processor into a single device. This allows the overall BOM to be reduced
significantly making the MSD9WB7PX-2 a very competitive multi-media DTV solution. For ATV users, the
MSD9WB7PX-2 provides multi-standard analog TV support with adaptive 3D video decoding and VBI data
extraction. The build-in audio decoder is capable of decoding FM, AM, NICAM, A2, BTSC and EIA-J sound
standards. The MSD9WB7PX-2 supplies all the necessary A/V inputs and outputs to complete a receiver
design including a multi-port HDMI receiver and component video ADC. All input selection multiplexed for
video and audio are integrated, including full SCART support with CVBS output. The equipped MStar
MACE-5 color engine is the latest masterpiece from MStar famous color engine series providing excellent
video and picture quality in Full-HD and large-scale displaying system. To meet the increasingly popular
energy legislative requirements without the use of additional hardware, the MSD9WB7PX-2 has an ultra low
power standby mode during which an embedded MCU can act upon standby events and wake up the
system as required.
8.2.General Features
MSD9WB9PX-2, an SOC solution that supports channel decoding, MPEG decoding, and media-centre
functionality enabled by a high performance AV CODEC and CPU Key features include,
39
LC-32SH130E
LC-32SH130K
LC-32SH340E
H.264 Decoder
ITU-T H.264, ISO/IEC 14496-10 (main and high profile up to level 4.1) video decoding
Supports resolutions for all DVB, ATSC, HDTV, DVD and VCD
Supports resolution up to 1080p@30fps
Supports CABAC and CAVLC stream types
Processing of ES and PES streams, extraction and provision of time stamps
Up to 40 Mbits bit rate (Bluray spec.)
Hardware JPEG
Supports NTSC-M, NTSC-J, NTSC-4.43, PAL (B, D, G, H, M, N, I, Nc), and SECAM standards
Automatic standard detection
Motion adaptive 3D comb filter
Five configurable CVBS & Y/C S-video inputs
Supports Teletext, Closed Caption (analog CC 608/ analog CC 708/digital CC 608/digital
CC 708), V-chip and SCTE
Audio Interface
One SIF audio input interface with minimal external saw filters
40
LC-32SH130E
LC-32SH130K
LC-32SH340E
41
LC-32SH130E
LC-32SH130K
LC-32SH340E
o
o
o
o
o
o
o
Output Interface
2D Graphics Engine
VIF Demodulator
Compliant with NTSC M/N, PAL B, G/H, I, D/K, SECAM L/L' standards
Audio/Video dual-path processor
Stepped-gain PGA with 25 dB tuning range and 1 dB tuning resolution
Maximum IF gain of 37 dB
Programmable TOP to accommodate different tuner gain and SAW filter insertion loss to
optimize noise and linearity performance
Multi-standard processing with single SAW
Supports silicon tuner low IF output architecture
DVB-T/DVB-C Demodulator
42
LC-32SH130E
LC-32SH130K
LC-32SH340E
Connectivity
Miscellaneous
43
LC-32SH130E
LC-32SH130K
LC-32SH340E
8.3.MSTAR Block Diagram
8.4.Reset Circuit
Reset circuit using for initializing main MStar IC. Reset condition is high and normal working condition is low
for RESET pin.
44
LC-32SH130E
LC-32SH130K
LC-32SH340E
9. CI INTERFACE
9.1
Block Diagram
9.2
It is used for CI module supply, when Module is inserted (it means CI detect is low) This circuit is opened or
closed by CI_POWER_CTRL port of main Controller
45
LC-32SH130E
LC-32SH130K
LC-32SH340E
10.
11.
USB INTERFACE
Main Concept IC has integrated 2 USB 2.0 interface. One of them is used for Ethernet function, the other
one is used for USB connectivity for last user. Last user can play video, picture and audio files. Also digital
channels can be record to external storage device by this interface. All SW files can be updated with
interface.
USB circuit has 3 main parts
46
LC-32SH130E
LC-32SH130K
LC-32SH340E
11.
12.
11.1
12.1.
General Description
12.2.
11.2
Features
The W9751G6JB is a 512M bits DDR2 SDRAM, organized as 8,388,608 words 4 banks 16 bits. This device
achieves high speed transfer rates up to 1066Mb/sec/pin (DDR2-1066) for general applications.
W9751G6JB is sorted into the following speed grades: -18, -25 and -3. The -18 is compliant to the DDR21066/CL7 specification. The -25 is compliant to the DDR2-800 (5-5-5) or DDR2-800 (6-6-6) specification.
The -3 is compliant to the DDR2-667 (5-5-5) specification. All of the control and address inputs are
synchronized with a pair of externally supplied differential clocks. Inputs are latched at the cross point of
differential clocks (CLK rising and CLK falling). All I/Os are synchronized with a single ended DQS or
differential DQS- DQS pair in a source synchronous fashion.
11.3
12.3.
47
LC-32SH130E
LC-32SH130K
LC-32SH340E
12.4.
11.4
Pinning
48
LC-32SH130E
LC-32SH130K
LC-32SH340E
49
LC-32SH130E
LC-32SH130K
LC-32SH340E
12.
13.
12.1
13.1.
13.2.
12.2
This switch is used to open and close panel supply of TCON. It is controlled by port of main Controller.
Also with this circuit panel sequence could be adjusted correctly. 3 panel supplies are connected to this
circuit. All of them are optional according to panels.
50
LC-32SH130E
LC-32SH130K
LC-32SH340E
51
LC-32SH130E
LC-32SH130K
LC-32SH340E
13.
14.
14.1.
13.1
General Description
13.2
14.2.
Features
MX25L1005 is a CMOS 1,048,576 bit serial Flash memory, which is configured as 131,072 x 8 internally.
The MX25L1005 feature a serial peripheral interface and software protocol allowing operation on a simple
3-wire bus. The three bus signals are a clock input (SCLK), a serial data input (SI), and a serial data output
(SO). SPI access to the device is enabled by CS# input. The MX25L1005 provide sequential read operation
on whole chip. After program/erase command is issued, auto program/ erase algorithms which program/
erase and verify the specified page or sector/block locations will be executed. Program command is
executed on page (256 bytes) basis, and erase command is executes on chip or sector(4K-bytes) or
block(64K-bytes). To provide user with ease of interface, a status register is included to indicate the status
of the chip. The status read command can be issued to detect completion status of a program or erase
operation via WIP bit. When the device is not in operation and CS# is high, it is put in standby mode and
draws less than 10uA DC current. The MX25L1005 utilize MXIC's proprietary memory cell, which reliably
stores memory contents even after 100,000 program and erase cycles.
14.3.
13.3
RATING
13.4
14.4.
14.4.
Pinning
VALUE
0C to 70C
Storage Temperature
-55C to 125C
-0.5v to 4.6v
-0.5v to 4.6v
-0.5v to 4.6v
Pinning
SYMBOL
DESCRIPTION
CS#
Chip select
SI
SO
SCLK
Clock Input
HOLD#
VCC
SYMBOL
DESCRIPTION
GND
CS#
Chip select
SI
52
Ground
LC-32SH130E
LC-32SH130K
LC-32SH340E
14.
15.
14.1
15.1.
General Description
The NAND flash 528-byte/ 264-word page is a family of non-volatile flash memories that uses the single
level cell (SLC) NAND technology. It is referred to as the small page family.
The NAND512R3A2C, NAND512R4A2C, and NAND512W3A2C have a density of 512 Mbits and operate with
either a 1.8 V or 3 V voltage supply. The size of a page is either 528 bytes (512 + 16 spare) or 264 words
(256 + 8 spare) depending on whether the device has a x8 or x16 bus width.
The address lines are multiplexed with the Data Input/output signals on a multiplexed x8 or x16
input/output bus. This interface reduces the pin count and makes it possible to migrate to other densities
without changing the footprint.
To extend the lifetime of NAND flash devices it is strongly recommended to implement an error
correction code (ECC). The use of ECC correction allows to achieve up to 100,000 program/erase cycles
for each block. A write protect pin is available to give a hardware protection against program and erase
operations.
14.2
15.2.
Features
NAND interface
Page size
Block size
Page read/program
53
LC-32SH130E
LC-32SH130K
LC-32SH340E
14.3
15.3.
Electronic signature
Chip Enable dont care
Security features
o OTP area
Serial number (unique ID) option
Hardware data protection
o Program/erase locked during power transitions
Data integrity
o 100,000 program/erase cycles (with ECC)
o 10 years data retention
RoHS compliant packages
Development tools
o Error correction code models
o Bad blocks management and wear leveling algorithms
Pinning
54
LC-32SH130E
LC-32SH130K
LC-32SH340E
General Description
The AX88772A/AX88172A Low-pin-count USB 2.0 to 10/100M Fast Ethernet controller is a high
performance and highly integrated ASIC which enables low cost, small form factor, and simple plug-andplay Fast Ethernet network connection capability for desktops, notebook PCs, Ultra-Mobile PCs, docking
stations, game consoles, digital-home appliances, and any embedded system using a standard USB port.
The AX88772A/AX88172A features a USB interface to communicate with a USB Host Controller and is
compliant with USB specification V1.1 and V2.0. The AX88772A/AX88172A implements 10/100Mbps
Ethernet LAN function based on IEEE802.3, and IEEE802.3u standards with 24KB of embedded SRAM for
packet buffering. The AX88772A/AX88172A integrates an on-chip 10/100Mbps Ethernet PHY to simplify
system design.
The AX88172A provides an optional External Media Interface (EMI) for external PHY or external MAC for
different application purposes. The EMI can be a media-independent interface (MII) for implementing
100BASE-FX Ethernet or HomePNA functions. The EMI can also be a Reverse-MII or Reverse Reduced-MII
(Reverse-RMII) for glueless MAC-to-MAC connections to any MCU with Ethernet MAC MII or RMII interface.
In addition, the EMI can be configured to Dual-PHY mode allowing AX88172A to act as an Ethernet PHY or
USB 2.0 PHY for external MAC device that needs Ethernet and USB interfaces in their system applications.
The optional serial interface such as I2C, SPI, and UART are provided as a control channel from the USB
Host Controller to communicate with the external MCU chip.
16.2.
15.2
Features
Integrates on-chip USB 2.0 transceiver and SIE compliant to USB Spec 1.1 and 2.0
Supports USB Full and High Speed modes with Bus-Power or Self-Power capability
Supports 4 or 6 programmable endpoints on USB interface
High performance packet transfer rate over USB bus using proprietary burst transfer
mechanism
Supports USB to Ethernet bridging or vice versa in hardware
55
LC-32SH130E
LC-32SH130K
LC-32SH340E
Supports Suspend Mode and Remote Wakeup via Link-up, Magic packet, MS wakeup frame
and external pin
Optional PHY power down during Suspend Mode
15.3
16.3.
Optional MII interface in MAC mode allows AX88172A to work with external 100BASE-FX
Ethernet PHY or HomePNA PHY
Optional Reverse-MII or Reverse-RMII interface in PHY mode allows AX88172A to work with
external HomePlug PHY or glueless MAC-to-MAC connections
Optional Reverse-MII interface in Dual-PHY mode allows AX88172A to act as an Ethernet
PHY or USB 2.0 PHY for external MAC device that needs Ethernet and USB in system
application
Supports 256/512 bytes (93c56/93c66) of serial EEPROM (for storing USB Descriptors)
Supports automatic loading of Ethernet ID, USB Descriptors and Adapter Configuration
from EEPROM after power-on initialization
Provides optional serial interface, I2C, SPI and UART
Integrates on-chip voltage regulator and only requires a single 3.3V power supply
12MHz and 25Mhz clock input from either crystal or oscillator source
Integrates on-chip power-on reset circuit
Block Diagram
15.4
16.4.
Pinning
56
17.
LC-32SH130E
LC-32SH130K
LC-32SH340E
16.
17.
17.1.
16.1
General Description
The LM1117 is a series of low dropout voltage regulators with a dropout of 1.2V at 800mA of load current. It
has the same pin-out as National Semiconductors industry standard LM317. The LM1117 is available in an
adjustable version, which can set the output voltage from 1.25V to 13.8V with only two external resistors. In
addition, it is also available in five fixed voltages, 1.8V, 2.5V, 2.85V, 3.3V, and 5V. The LM1117 offers
current limiting and thermal shutdown. Its circuit includes a zener trimmed band-gap
reference to as-sure output voltage accuracy to within 1%. The LM1117 series is available in SOT- 223,
TO-220, and TO-252 D-PAK packages. A minimum of 10F tantalum capacitor is required at the output to
improve the transient response and stability.
17.2.
16.2
16.3
17.3.
Features
16.4
17.4.
17.5.
16.5
Pinning
57
LC-32SH130E
LC-32SH130K
LC-32SH340E
17.
18.
MP2012 (U176)
18.1.
17.1
General Description
17.2
18.2.
Features
The MP2012 is a fully integrated, internally compensated 1.2MHz fixed frequency PWM step-down
converter. It is ideal for powering portable equipment that runs from a single cell Lithium-Ion (Li+) Battery,
with an input range from 2.7V to 6V. The MP2012 can provide up to 1.5A of load current with output voltage
as low as 0.8V. It can also operate at 100% duty cycle for low dropout applications. With peak current mode
control and internal compensation, the MP2012 is stable with ceramic capacitors and small inductors. Fault
condition protection includes cycle-by-cycle current limiting and thermal shutdown.
17.3
18.3.
Pinning
Pin
#
Name
Description
FB
GND, Exposed
Pad
SW
PVIN
VIN
EN
58
LC-32SH130E
LC-32SH130K
LC-32SH340E
18.
19.
19.1.
18.1
General Description
18.2
19.2.
Features
The RT8283A is a high-efficiency, monolithic synchronous step-down DC/DC converter that can deliver up
to 3A output current from a 4.5V to 23V input supply. The RT8283A's current mode architecture and
external compensation allow the transient response to be optimized over a wide range of loads and output
capacitors. Cycle-by-cycle current limit provides protection against shorted outputs and soft-start eliminates
input current surge during start-up. The RT8283A also provides output under voltage protection and thermal
shutdown protection. The low current (<3A) shutdown mode provides output disconnect, enabling easy
power management in battery powered systems. The RT8283A is available in a SOP-8 package.
59
LC-32SH130E
LC-32SH130K
LC-32SH340E
18.3
19.3.
Pinning
Pin No.
1
Pin
Name
BOOT
Description
VIN
SW
4, 9 (Exposed
Pad)
GND
FB
COMP
EN
SS
Ground.
60
LC-32SH130E
LC-32SH130K
LC-32SH340E
19.
20. MP1583 (U174)
20.1.
19.1
General Description
20.2.
19.2
Features
The MP1583 is a step-down regulator with a built-in internal Power MOSFET. It achieves 3A of continuous
output current over a wide input supply range with excellent load and line regulation. Current mode
operation provides fast transient response and eases loop stabilization. Fault condition protection
includes cycle-by-cycle current limiting and thermal shutdown. An adjustable soft-start reduces the
stress on the input source at start-up. The MP1583 requires a minimum number of external components,
providing a compact solution.
3A Output Current
Programmable Soft-Start
100m Internal Power MOSFET Switch
Stable with Low ESR Output Ceramic Capacitors
Up to 95% Efficiency
20A Shutdown Mode
Fixed 385KHz Frequency
Thermal Shutdown
Cycle-by-Cycle Over Current Protection
Wide 4.75V to 23V Operating Input Range
Output Adjustable from 1.22V to 21V
Under-Voltage Lockout
19.3
20.3.
Pinning
Pin
No.
Pin
Name
Description
BOOT
IN
SW
Power Switching Out is the switching node that supplies power to the
output
GND
FB
COMP
EN
SS
High-Side Gate Drive Bootstrap Input. BS supplies the drive for the
high-side N-Channel MOSFET switch.
Ground.
Feedback Input. FB senses the output voltage and regulates it. Drive
FB with a resistive voltage divider from the output voltage. FB
threshold is 1.222V.
61
LC-32SH130E
LC-32SH130K
LC-32SH340E
20.
21.
FDC642
21.1.
20.1
General Description
This P-Channel 2.5V specified MOSFET is produced using Fairchilds advanced PowerTrench process that
has been especially tailored to minimize on-state resistance and yet maintain low gate charge for
superior switching performance.
These devices have been designed to offer exceptional power dissipation in a very small footprint for
applications where the larger packages are impractical.
21.2.
20.2
Features
21.3.
20.3
62
LC-32SH130E
LC-32SH130K
LC-32SH340E
21.
22.
FDC604P
22.1.
21.1
General Description
22.2.
21.2
Features
This P-Channel 1.8V specified MOSFET uses Fairchilds low voltage PowerTrench process. It has been
optimized for battery power management applications.
21.3
22.3.
63
LC-32SH130E
LC-32SH130K
LC-32SH340E
22.
23.
CONNECTORS
22.1
23.1.
SCART (SC1)
22.2
23.2.
HDMI (CN707,CN708)
23.3.
VGA (CN132)
64
LC-32SH130E
LC-32SH130K
LC-32SH340E
23.3.
23.3
VGA (CN132)
65
LC-32SH130E
LC-32SH130K
LC-32SH340E
24.
23.
In order to reach service menu, First Press MENU Then press the remote control code two times,
which is 4725.
In first screen following items can be seen:
66
LC-32SH130E
LC-32SH130K
LC-32SH340E
24.1.
23.1
24.1.
24.2.
23.2
24.2.
Video Settings
Video Settings
Audio Settings
Audio Settings
67
LC-32SH130E
LC-32SH130K
LC-32SH340E
Options
23.3 Options-1
Options
Options-2
68
LC-32SH130E
LC-32SH130K
LC-32SH340E
24.3.
Tuning Settings
23.4 Tuning
Settings
24.4.
Source Settings
69
LC-32SH130E
LC-32SH130K
LC-32SH340E
23.6
Diagnostic
24.5.
23.7
Diagnostic
USB Operations
24.6.
USB Operations
USB operations option cannot be used directly. It can be used for updating panel tool, hw configuration
etc.
25.
SOFTWARE UPDATE
In MB60 project there is only one software. From following steps software update procedure can be seen:
70
https://www.vestelservice.com/100359/New_Projects/Sharp/Sharp_2011/9_Customer_support/SW/
LC-32SH130E
LC-32SH130K
LC-32SH340E
SOFTWARE UPDATE
1.
2.
3.
4.
5.
mb60_en.bin
mboot.bin
usb_auto_update.txt
Turn power to OFF by mechanical switch(rocker switch) or removing AC
plug. And plug the USB to TV
Keep pressing OK key from remote controller and then turn the TV power
to ON(by mechanical switch or by inserting the AC plug) and keep OK key
pressed until the stanby led blinks rapidly(rapid blinking is faster than
normal blinking)
When the led is started to blink rapidly, you can release the OK key.Please
wait approximately for 1-2 minutes.
When the blinks of led is stopped, TV opens autamatically with the new
SW.
71
LC-32SH130E
LC-32SH130K
LC-32SH340E
2.14
2.14.1
The HOTEL TV is a special mode which restricts some operations of TV. This allows the customer to use the TV
in hotels or in Hospitals. The restrictions of a hotel TV are basically given below.
1.
2.
3.
4.
5.
6.
7.
8.
9.
2.14.2
The user cannot increase the volume above a specified limit. And could set fixed volume.
The user could enable headphone direct volume control.
The user cannot reach some menus.
The user cannot use panel.
Start up source position can be limited for the user.
Last status could be used or not
Teletext could be disabled or enabled.
NVRAM data (like service list and user preferences, etc.) could be copied or set via USB device
Pin8 could be used or not
HOTEL TV MENU:
To enter hotel menu, please open main menu by pressing MENU(M) button. When you code following password
7935, hidden hotel TV menu appears.
2.14.3
Hotel Mode
Setting Hotel Mode item 'On' activates hotel mode. In other words user can do only what he/she is allowed to
do. Restriction level can be determined by using other items on menu namely Volume Limit, Panel Button, OSD
Disable. In hotel mode, users can not reach channel table and install menu so they could not change any
program information.
2.14.4
Last Status
Setting Last Status item to 'On' enable TV open with the closing status. Otherwise, if Last
Status item is set 'Off' TV opens with standby status.
2.14.5
Panel Lock
Enables (Panel Lock = On) or prohibits (Panel Lock = Off) the use of front panel buttons.
2.14.6
RCU Inhibit
If OFF is selected TV will go on normal operation. If it is ON RCU will not function in any menu (including no
menu) except this menu. To turn this option OFF later, hotel TV menu shortcut (MENU(M)-7-9-3-5) can be
used to pop up this menu.
2.14.7
Startup Position
Specifies the starting channel when TV is switched ON. May take one of following values:
AUTO (Last channel when TV is turned off)
72
LC-32SH130E
LC-32SH130K
LC-32SH340E
Startup Channel
Specifies the starting TV channels ID which will be tuned when startup position is TV
2.14.9
Volume Limit
Sets the maximum value the volume can have. Volume Limit can take values between 0-63.
2.14.10 Fixed Volume Enable
Enables (Fixed Volume Enable = On) or prohibits (Fixed Volume Enable = Off) the use of fixed volume value
which is set by menu item Fixed Volume Value. If Fixed Volume Enable is ON, volume cannot be set to a
value other than the Fixed Volume Value.
2.14.11 Fixed Volume Value
Sets the fixed value the volume can have. If Fixed Volume Limit is ON, volume is set with the value here.
2.14.12 Headphone Direct Volume
Enables to could set via headphone volume dialog the headphone volume level.
If it is changed to enable then V+/- keys will change HP volume and left/right option will change speaker
volume unless there is any open OSD. If it is disabled it will behave as normal.
Volume control and HP volume control are displayed by volume slider menu.
2.14.13 OSD Disable
Disables either only INSTALL menu or all menus, both in analog and digital (IDTV) mode.
OSD Disable = Disable All Menus
INSTALLATION) are invisible.
73
LC-32SH130E
LC-32SH130K
LC-32SH340E
74
LC-32SH130E
LC-32SH130K
LC-32SH340E
There is a wakeup time channel option in hotel mode menu, It is used to set the channel, whose time
information to be used for wakeup timer. If this option is 0 time information of the channel which is being
watched when timer menu is opened, will be used. Otherwise a please wait message will be displayed before
the menu is open and during please wait time information of the channel will be get. (This can take up to
30s). The wakeup time channel should be a digital service.
2.14.24 Pin8
If ON is selected Pin8 will go on normal operation. If It is OFF Pin8 ignored.
2.15 OSD Menu Tree
Main Menu
Picture
o
o
o
o
o
o
o
o
o
o
o
Sound
o
o
o
o
o
o
o
o
Settings
o
o
Mode
Contrast
Brightness
Sharpness
Colour
Colour Shift
Colour Temp
Noise Reduction
Picture Zoom
PC Position (PC mode only)
Autoposition
H position
V position
Dot Clock
Phase
Reset
Volume
Equalizer
Balance
Headphone
Sound Mode
AVL
Dynamic Bass
Digital Out
<0:63>
<User, Music, Movie, Speech, Flat, Classic >
<-31, +31>
<0:63>
<Stereo, Dual I, Dual II>
<On, Off>
<On, Off>
<PCM, Compressed>
Conditional Access
Language
Menu
Preferred
Audio
Subtitle
Teletext
Guide
Current
Audio
Subtitle
Parental
Parental Lock
Maturity Lock
Child Lock
Set PIN
Timers
Sleep timer
75
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.
TROUBLESHOOTING
26.1.
No Backlight Problem
Problem: If TV is working, led is normal and there is no picture and backlight on the panel.
Possible causes: Backlight pin, dimming pin, backlight supply, stby on/off pin
Backlight pin should be high in open position. If it is low, please check Q181 and panel cables.
Dimming pin should be high or square wave in open position. If it is low, please check S16 for Mstar side
and panel or power cables, connectors.
Backlight power supply should be in panel specs. Please check CN705 for MB60, related connectors for
power supply cards.
76
LC-32SH130E
LC-32SH130K
LC-32SH340E
77
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.2.
CI Module Problem
78
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.3.
79
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.4.
IR Problem
80
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.5.
81
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.6.
USB Problems
82
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.7.
No Sound Problem
26.8.
26.9.
83
LC-32SH130E
LC-32SH130K
LC-32SH340E
26.11.
26.10
No Signal Problem
84
LC-32SH130E
LC-32SH130K
LC-32SH340E
TH1
R1595
10k
R1551
100R
R1589
12k
R1550
100R
C901
100n
10V
1
C903
100n
10V
1 B1
U3
S 6
C14
10V
100n
6k8
R474
1
50V
RF_AGC_TUNER
SIFM
22k
R594
R1580
47R
680R
R735
L114
1u
SIF_CTL
0R
R209
100k
1
Q140
2
BSN20
Q144
BF799
0R
82p 47p
2
SIFP
C902
100n
10V
Z102
1 IN1
OUT1 4
K3958M
OUT2 5
2 IN2
GND
C547
1
10n
16V
VIFM
R1549
100R
5V_TUN
B
VIFP
5V_VCC
RF_AGC_CTL
R1590
10k
ANT_CTRL
10k
R1593
10k
R4
A 4
VCC 5
R483
1k2
R1857
200R
10n
C1210
47p
50V
RF_AGC_MONITOR
FSA3157
2 GND
100k
R1934
S28
3 B0
Q172
BC848B
L124
ANALOG_IF
D145
BA782
NC
R231
3k3
2
2
R1581
1k
FDN336P
Q175
F260
41MHz
C914
4
3
R1565
10k
1
2
X1
3V3_DVDD
10V
100n
C955
1V2_CVDD
C965
100n
16V
RF_AGC_MST
R473
6k8
1
3V3_VCC
12V_VCC
150nH
C545
3V3_DVDD
C3
22u
16V
R1594
10k
TUN_SCL_T2
5V_TUN
Q205
BC848B
1
10k
R1564
R384
10R
R1932
100k
1V2_MVDD
330R
C954
B1
ANT_PWR
5 R4 4
R1592
10k
TUN_SCL_MST
F266
R139
1k
12V_VCC
R252
4k7
C135
100n
10V
6 R3 3
Q207
BC848B
R1582
1k
RF_AGC_TUNER
330R
5V_TUN
F261
100n
10V
C907
TUN_SDA_MST
TUN_SDA_T2
R1939
10k
Z101
1 IN1
OUT1
K9656M
OUT2
2 IN2
GND
10n
16V
RF_AGC_CTL
C143
2
1
47p
50V
2
1
C1211
1u
C964
5V_TUN
3V3_VCC
7 R2 2
OVER_CUR_DETECT
R1591
10k
R1588
100R
8
1
R1
16V
C904
22u
100n C2
10V
2K7
C546
R138
1k
2V5_VCC
600R
1V2_PVDD
RF_AGC
5V_TUN
SCL
IF_AGC_TUNER
S100
5V_TUN
C910
100n
10V
16V
47u
IF_AGC_TUNER
2
50V
12p
B2
12p
50V
IF_AGC_T2
DIGITAL_IF_N
R1552
100R
C912
100n
10V
1
5V_TUN
R1597
10k
R1545
100R
NC
N.C.
R1546
100R
R1933
100k
10
R1596
10k
10
AS
SDA
120nH
L115
11
IF_AGC_MST
DIGITAL_IF_P
R1598
6k8
DIF2
IF_AGC
11
2R1
12
DIF1
12
47p150p
50V
ANALOG_IF
AIF
5V_TUN
5V_TUN
2u2
L104
R1586
20k
RESET_T2
47R
R1856
R1560
10k
R1561
10k
3V3_DVDD
33
A0
OSCENBN
34
36
37
35
VSS7
CVDD5
RESETN
38
39
5 R4 4
TS_MDI7
TUN_SDA_T2
57
TUNERDAT
TSDATA6
24
6 R3 3
TS_MDI6
TUN_SCL_T2
58
TUNERCLK
TSDATA5
23
7 R2 2
TS_MDI5
59
DVDD
TSDATA4
22
TS_MDI4
60
VSS9
VSS4
21
R1
1
47R
R1584
61
CVDD
CVDD3
20
62
PLLBPN
MVDD2
19
63
RFAGC_GPIO1
MVSS2
18
64
IFAGC
TSDATA3
17
33R
TSDATA2
VSS3
32
VSS6
31
CVDD4
30
85
SCL_SYS
1V2_CVDD
1V2_MVDD
R1583
47R 33R
5 R4 4
TS_MDI3
6 R3 3
TS_MDI2
7 R2 2
TS_MDI1
R1
TS_MDI0
F
A3
TOTAL SHEET:9
DRAWN BY :MB60_HW_TEAM
SDA_SYS
47R
R1575
3V3_DVDD
33R
C953
12p
50V
TSMICLK
TSMIVALID
TSMISYNC
1V2_CVDD
R1576
47R
16
15
CVDD2
14
TSDATA1
TSDATA0
13
12
VSS2
DVDD1
11
10
MVSS1
9
MVDD1
CVDD1
TESTMODE
1V2_CVDD
33R
3V3_DVDD
33R
1V2_MVDD
C911
IF_AGC_T2
1V2_CVDD
VSS1
TSCLK
U167
CXD2820R
R1566
10k
T2 DEMOD
MVSS3
25
D6
C15V
OSCMODE
TSDATA7
10V
100n
C15V
1
D2
10V
C935
MVDD3
CVDD6
3V3_DVDD
10V
C933
40
26
F262
10V
C917
41
VSS5
56
10V
C932
100n
42
VSS8
3V3_RVDD
100n
MVDD4
55
3V3_DVDD
330R
100n
MVSS4
27
F265
330R
100n
43
DVDD2
1V2_CVDD
C957
22u
16V
44
RVDD
3V3_VCC
PVSS
54
10V
C916
PVDD
28
1V2_CVDD
330R
100n
45
29
SCL
3V3_RVDD
2V5_AVDD
XVDD
SDA
RFAIN
100n
F267
XTALO
AVDD1
53
10V
C931
2V5_VCC
46
52
2V5_AVDD
1V2_PVDD
330R
47
AVSS1
10V
C928
AINP
51
47R
R1579
10V
C927
DIGITAL_IF_P
S96
TSVALID
10V
C929
AINM
50
C918100n
10V
100n
10V
TSSYNC
100n
C915
49
DIGITAL_IF_N
100n
F264
100n
S97
XTALI
10V
C923
TSERR_GPIO2
100n
10V
C919
100n
10V
C925
R1578
47R
R1573
47R
D5
100n
10V
C922
1V2_MVDD
330R
C956
22u
16V
100n
10V
C921
330R
100n
10V
C920
GPIO0
1V2_VCC
F269
100n
XVSS
1V2_CVDD
330R
F134
48
F263
C15V
SCHEMATIC DIAGRAMS
27. Schematic Diagrams
TU102 TDTC-G101D
24-05-2011_13:42
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
Peripherals Diagram
5
SCART
R1480
75R
50V
220p
2
600R
R1244
100R
IPOD_Y_IN
IPOD_C_IN
F198
1
600R
14
MAIN_R
SDA_SYS
R1938
100R 56R
1
8
R1
R1506
33R
IPOD_L_IN
600R
13
12
11
10
SCL_SYS
RX/SCL_SC
3 R3 6
TX/SDA_SC
4 R4 5
16V
R1407
33R
RCA_PR
R1508
33R
MAIN_L
R1511
33R
IPOD_DETECT
1
600R
C824
1
16V
R1405
33R
RCA_Y
F207
2 R2 7
IR_IN
RCA_PB
RCA_Y
16V
R1406
33R
R1494
470R
27p
50V
CN133
Y6
SC_FB
C881
U2
47n
16V C805U3
47n
C883
T2
47n
16V C803T1
47n
C886
R1
47n
16V C804 R2
47n
T3
C859
1n
V4
50V
R103
68k
R1311
10k
R1310
10k
R1265
10k
1
SAV_R_IN
220p
50V
C830
C5V6
D171
C855
3n3
50V
7
JK2
S103
YPbPr INPUT
TP246
RCA_PR
4
2
TP248
RCA_Y
SOGIN1
HSYNC1
VSYNC1
RIN2M
IR_IN
DVD_IR
R694
4k7
RIN2P
JK4
6
5
S9
SAV_CVBS_IN
YEL
GIN2M
GIN2P
4
3
S42
SAV_L
WHT
BIN2M
DVD_IR_ON/OFF
2
1
S39
SAV_R
RED
BIN2P
SOGIN2
HSYNC2
BIN1P
RCA_PB
1
TP249
S101
BIN1M
27p 50V
75R
R1619
75R
R1620
75R
R1621
S102
C828
86
A3
TOTAL SHEET:9
DRAWN BY :MB60_HW_TEAM
SAV_R
C823
15
AMP_MUTE
U157
MSD9WB7PX-2
GIN1P
SAV_L_IN
16
SC_CVBS_IN
F199
IPOD_R_IN
SC_B
17
SC SVHS opt
50V 27p
18
5V_STBY
GIN1M
3n3
C829
19
S79
S78
NC
RIN1P
50V
C856
F203
SAV_L 600R
F202
TP247
600R
21
20
SC_G
W1
TP250
SC_R
VCOM
2 NUP4004M5
4
D177
5
22
VSYNC0
RIN1M
4
JK3
1
3
23
16V C882
R3
47n
R1418 16V C798
P2
33R
47n
R1510
16V C885
P3
33R
47n
R1417
47n C797N2
33R
16V
R1509
16V C884
N3
33R
47n
C796
R1416
M1
33R
16V47n
R1505
C862
N1
33R
1n 50V
W6
SAV_CVBS_IN
CVBSOUT1 AA4
R1507
33R
SAV_CVBS_IN
24
SCART_CVBS_OUT
DVD_C_IN
R263
4k7
25
CVBSOUT0
TP245
26
HSYNC0
V3
DVD_Y_IN
DVD_WAKEUP
N5
VGA_VSNC
12V_VCC
CVBS5
SOGIN0
IPOD_C_IN
SC_R
S93
IPOD_Y_IN
BC848B
Q157
27
BIN0P
W2 16V
47n
W3
29
28
CVBS4
2
2
IPOD INTERFACE
30
BIN0M
R1413
16V C800
33R
47n
R1414
C801
33R
16V C799 R1412
33R
47n
R1411
C794
33R
16V C793 R1410
33R
47n
SC_CVBS_IN
10
S80
C972
12V_VCC
GIN0P
W5 16V
47n
CVBS3 AA5
50V
220p
VGA_G
CVBS2
R1415
33R
R498
47k
TP1
DVD_IR
C650
TP4
VGA_B
12V_VCC
4A/24VDC
8
1
R1623
100R
DVD_SPDIF
50V
27p
4k7
R1616
TP43
TP42
FS1
GIN0M
C795
D181
TP5
C18V
TP39
RIN0P
16V
CVBS0 AC5
47n
CVBS1 W4
RIN0M
DVD_SENSE
TP44
TP242
3
R1624
100R
10u
25V
DVD_C_IN
R1420
M2
33R
R1409
C807
47n
M3
33R
16V
R1422
16V C810
L2
33R
47n
R1408
16V C806 L3
33R
47n
R1421
16V C809
K1
33R
47n
R1419
16V C802K3
33R
47n
R1423
C861
K2
470R
50V 1n
N4
VGA_HSNC
75R
R12 R1486
270R
R11
270R
VGA_R
50V
47n
16V
C808
VGA_G
C973
DVD_Y_IN
R1653
75R
R1651
180R
VGA_R
SIDE AV INPUT
SC_AUD_R_OUT
R1245
100R
2
1 RED
4n7
50V
CN704
CN132
75R
R1484
TP38
VGA_G
VGA_R
SC_AUD_L_OUT
C858
JK7
VGA_B
VGA_G
600R
R1652
75R
R1650
180R
VGA_B
4n7
SC_AUD_R_IN 50V
F201600R
1
C857
3n3
F206
1
1
3
SCART_AUD_R_IN
2
600R
C854
50V
3
WHT
SC_AUD_L_IN
F200
4
YEL
75R
R1517
R15
75R
R10
75R
R9
75R
3
SC_CVBS_IN
F205
1
SCART_AUD_R_IN
100n
10V
C664
3n3
SC_PIN8
SCART_AUD_L_IN
4
3
INDIA OPTION
close to vga
connector!!
C853
50V
C831
75R
R1489
SCART_AUD_L_IN
75R
R1485
33R
R1530 C959 16V
R1182
4k7
SC_B
VGA_DDC_5V
75R
R1515
50V
220p
2K7
R1187
22k
12K
SC_G
C15V
2K7
10
75R
R1516
D178
2
RX/SCL_SC
VGA_HSNC
C832
75R
R1483
VGA_VSNC
100R
100R
2 NUP4004M5
4
D173
5
TX/SDA_SC
11
10u
10V
12p NC
50V
R1243
1
1
3
11
10
A
R1949
12
SCART_CVBS_OUT
VGA_DDC_5V
2k2
R1209
2k2
R1206
SC_CVBS_OUT
R620
300R
C788
C833
75R
R1481
75R
R1482
R1587
75R
12
Q119
BC848B
SC_FB
47n
SCART LT1
SC1
C378
C663
100n
10V
50V
220p
47R
R1249
SC_R
13
14
16
R102
390R
75R
R1479
1n
50V
TP13
15
Q146
BC858B
100R
R221
R104
33k
17
13
C120
10u
16V
SC_CVBS_OUT
C860
R1233
220R
14
330R
18
15
F179
1
220R
SC_CVBS_IN
50V
220p C836
2
R124
470R
220p
50V
C835
12V_VCC
20
19
NUP4004M5 2
4
D176
5
NUP4004M5 2
4
D174
5
1
3
1
3
NUP4004M5 2
4
D175
5
PC INPUT
21
8
5V_VCC
D169
BAV70
27p
10V
100n
C628
24-05-2011_13:43
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
TX_A_3_N
TX_A_3_P
PANEL_VCC
3
2
TP22
16
17
18
19
20
PANEL_VCC
21
22
S57
TX_B_CLK_P
TP24
TX_B_3_N
TP26
TP28
TP25
TX_A_0_N
23
24
25
26
TX_A_0_P
27
28
29
30
3V3_VCC
3V3_VCC
MEGA_DCR_OUT
TX_A_1_P
TP27
TP29
TX_A_2_N
TP31
TX_A_2_P
TP34
TX_A_CLK_N
1
S10
31
32
33
34
35
36
37
38
39
40
41
42
OPTION1
43
44
OPTION2
45
46
47
48
49
50
S4
OPTION6
TX_A_CLK_P
TP33
TX_A_3_N
TP35
TX_A_3_P
TP32
MEGA_DCR_IN
OPTION3
TP6
TX_A_4_P
TP7
TX_A_4_N
2
1
S55
TX_A_0_N
R1295
10k
TX_A_0_P
TX_A_1_N
TX_A_1_P
TX_A_2_N
TX_A_2_P
TX_A_CLK_N
TX_A_CLK_P
PANEL_VCC
30
29
S11
1
OPTION2
OPTION1
TX_B_2_P
TX_B_2_N
TX_B_1_P
TX_B_1_N
TX_B_0_P
TX_B_0_N
OPTION5
OPTION4
87
28
27
26
25
24
30
23
29
22
21
28
20
27
26
19
25
18
17
24
16
23
22
15
14
21
13
20
19
12
18
11
10
17
16
9
OPTION3
15
8
S98
14
6
13
5
12
11
3
4
TX_B_CLK_P
TX_B_CLK_N
A3
TOTAL SHEET:9
DRAWN BY :MB60_HW_TEAM
CN135
TX_A_CLK_P
TX_A_CLK_N
TX_B_4_P
TX_B_4_N
TX_B_3_P
TX_B_3_N
TX_A_4_P
TX_A_4_N
S72
TX_A_3_P
TX_A_3_N
1
2
S71
MEGA_DCR_OUT
R1275
10k
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
5V_VCC
R809
4k7
S35
S37
USB_ENABLE
PANEL_VCC
5V_VCC
10
S54
S2
PANEL_VCC = 5V/12V
S58
1
OPTION6
OPTION7
PANEL_VCC
OPTION1
MEGA_DCR_OUT
TX_A_3_N
PANEL_VCC
2
10k
R1300
S30
10k
R1266
10k
R1301
TX_A_3_P
S13
S14
S3
S99
TP30
TX_A_1_N
TX_B_3_P
CN139
S56
10k
R1280
EXT KEYPAD
S19
SDA_SYS
R1936
47R
SCL_SYS
OPTION2
R1937
47R
PANEL_VCC
1
1
14
15
PANEL_VCC
3V3_STBY
600R
S33
13
1
S94
F249
S32
TP20
TX_B_CLK_N
OPTION3
10k
R1274
TP9
TX_B_4_N
TP8
TX_B_4_P
KEYBOARD
S15
12
10
11
TX_A_CLK_P
TP18
TX_B_2_P
S34
11
10
S36
12
TX_A_2_P
TP16
TX_B_2_N
600R
S12
5V_VCC
R1198
47k
13
15
TX_B_1_P
PANEL_VCC
16
TX_A_1_P
TP17
OPTION7
TX_A_1_N
LED1
18
220R
R1570
2
100k
R884
1
TX_A_0_P
F248
1
19
OPTION5
R1296
PANEL_VCC
10k
R1297
10k
OPTION4
R793
47R
R1201
47k
USB_OCD
TX_A_0_N
1
C610
10u CN128
10V
5
1 OUT
IN
U149
2 GND
STMP2161
3 FAULT
EN 4
20
TP19
MECH_SWITCH
21
TX_B_3_P
1
1
S6
IO3 4
TX_B_3_N
TX_A_CLK_N
PANEL_VCC
3 IO2
22
C630
100n
10V
TX_B_CLK_P
CN702
2
KEYBOARD_ONBOARD
CN136
220R
R1572
R1562
10k
220R
R1571
S76
VDD 5
AZ099-04S
23
U145
R1563
10k
TOUCH_PAD_OPTION
MEGA_DCR_IN
Q181
BC848B
CN137
R845
10R
IO4 6
TP21
220R
R1940
D204
C15V
1
2
CN138
1 IO1
TX_B_1_N
3V3_STBY
3V3_STBY
3V3_STBY
2
1
25
C1015
100n
10V
R844
10R
TX_B_2_P
TX_B_CLK_N
BACKLIGHT_ON/OFF
S73
S74
HDMI0_5V
STBY_ON/OFF_NOT
18k
HDMI1_5V
LED1
LED2
1
R1606
R344
4k7
4k7
R1671
R1607
18k
C1031
22u
16V
2 GND
USB_DM
1
1
USB
USB_DP
S81
R1661
4k7
USB INTERFACE
E
SW1
NC
D189
R1667
10k
1N4148
220R
R1569
3V3_VCC
RESET
2
R1497
2k7
R1604
33k
R1605
33k
R1617
4k7
R1672
4k7
100n
10V
C1016
3V3_STBY
R1668
1k
LED2
3V3_VCC
PANEL_VCC_ON/OFF
PROTECT
DVD_IR_ON/OFF
R1614
P0_ETH
3V3_STBY
4k7
R1669
3V3_VCC
4k7
CI_POWER_CTRL R1952
3V3_VCC
4k7
AB8
H5
C5
K4
L5
M6
CN703
TP10
1
3V3_STBY
AMP_MUTE
RESET
1
GND0
GND1
4k7
R1959
F11
E11
SW2
2
SW4
1
R1601
4k7
R1618
4k7
R1663
4k7
GPIO6
GPIO7
GPIO10
GPIO11
GPIO17
GPIO18
TX_B_0_P
TX_A_2_N
HP_MUTE
3V3_STBY
PANEL_VCC
USB0_DP
USB0_DM
USB1_DP
USB1_DM
26
14
C2
B1
AD11
AE11
USB_DP_ETH
USB_DM_ETH
USB_DP
USB_DM
A7
C7
F4
E4
C3
D4
F6
F5
TX_B_2_N
17
GPIO32
GPIO33
GPIO34
GPIO35
GPIO36
GPIO37
GPIO44/UART1_RX
GPIO45/UART1_TX
RESET
BC858B
HWRESET
TX_B_0_N
TX_A_2_P
TX_A_2_N
TX_A_1_P
TX_A_1_N
TX_A_0_P
TX_A_0_N
E5
Q174
Q173
C951
18p
50V
T4
Q171
BC848B
100R
R7
100R
R1666
27
GPIO152
SW3
HP_DETECT
X2
R1533
1M
24MHz
XIN
XOUT
U157
MSD9WB7PX-2
AD1
AE2
R6
Y8
Y9
28
TX_B_1_P
C952
18p
50V
100R
R8
GPIO146
GPIO147
GPIO148
29
TX_B_1_N
24
R1568
10k
STBY_INFO
3V3_STBY
RESET_T2
4k7
R1656
R1659
3V3_VCC
4k7
OVER_CUR_DETECT
1
NC
1
IRIN
TX_B_0_P
5V_STBY
G5
30
TP23
TX_B_0_N
R1543
100R
BC858B
USB_ENABLE
IPOD_DETECT
DVD_SPDIF
PCM_CD1_N
USB_OCD
27p
50V
IR_IN
DDCR_CK
DDCR_DA
IR_IN
600R
C949
Q170
BC848B
R1567
10k
AA23
AA24
SCL_SYS
SDA_SYS
AA10
T5
AB10
AB7
AA9
V5
AC11
AA8
CN709
GPIO137
GPIO138
GPIO139/SPDIFI
GPIO140
GPIO141
GPIO142
GPIO143
GPIO144
TX_A_0_P
TX_A_0_N
TX_A_1_P
TX_A_1_N
TX_A_2_P
TX_A_2_N
TX_A_CLK_P
TX_A_CLK_N
TX_A_3_P
TX_A_3_N
TX_A_4_P
TX_A_4_N
STBY
3V3_VCC
DDCA_CK/UART0_RX
DDCA_DA/UART0_TX
P6
N6
RX/SCL_SC
TX/SDA_SC
R1524
4k7
R1527
4k7
3V3_VCC
5V_STBY
F259
1
SPI_CSN_1
SPI_SCK
SPI_SDI_1
SPI_SDO
FLASH_WPN
NC
GPIO12
SCZ
SCK
SDI
SDO
GPIO14
P/VOL
R1498
1k2
C4
A4
A2
B3
A3
B2
AC20
AD21
AE20
AD20
AE19
AC19
AC18
AD19
AC17
AD18
AE17
AD17
LVA0P
LVA0M
LVA1P
LVA1M
LVA2P
LVA2M
LVACKP
LVACKM
LVA3P
LVA3M
LVA4P
LVA4M
LED SOCKET
KEYBOARD_ONBOARD
R1662
4k7
ONBOARD KEYBOARD
TX_B_0_P
TX_B_0_N
TX_B_1_P
TX_B_1_N
TX_B_2_P
TX_B_2_N
TX_B_CLK_P
TX_B_CLK_N
TX_B_3_P
TX_B_3_N
TX_B_4_P
TX_B_4_N
R1294
10k
R1
4k7
R1522
4k7 NC
4k7
R1523 NC
SAR0
SAR1
SAR2
SAR3
AC24
AC25
AD24
AD25
AE24
AC23
AE23
AD23
AE22
AC22
AC21
AD22
LVB0P
LVB0M
LVB1P
LVB1M
LVB2P
LVB2M
LVBCKP
LVBCKM
LVB3P
LVB3M
LVB4P
LVB4M
R1528
4k7
2
DVD_WAKEUP
J5
G4
B4
AA7
KEYBOARD
DVD_SENSE
SC_PIN8
RF_AGC_MONITOR
3V3_STBY
PWM0
PWM1
PWM2
PWM3
3V3_STBY
AB25
AB24
E6
D6
R1499
270R
CFG_PWM0
CFG_PWM1
R1615
3V3_VCC
4k7
BACKLIGHT_DIM
24-05-2011_13:43
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
HP_L
HPL_MUTE
R1858
200R
B
2
HP_R
HPR_MUTE
10u
R1859
200R
AUVRP
AUVAG
AUVRM
C1174 C1199
10V
100n
10V
10u
3V3_VCC
ANT_CTRL
L120
100u
16V
AB4
AB5
AC3
220R
C1170
10u
10V
C1169
EAR_OUTL
EAR_OUTR
DSP_HP_L
10u
100u
16V
DSP_HP_L
DSP_HP_R
AD5
AE5
L119
DSP_HP_R
C1201
1u
6V3
C1200
4u7
10V
I2S_OUT_BCK
3V3_VCC
220R
4k7
R1674
C1171
10u
10V
3V3_VCC
RST_ETH
TP223
4k7
R1894
SPDIF_OUT
DSP_SCART_L
I2S_OUT_MCK
I2S_OUT_SD
I2S_OUT_WS
I2S_OUT_BCK
C1
H6
G6
I2S_IN_BCK
I2S_IN_SD
I2S_IN_WS
P5
HDMI1_5V
D2
E3
E2
F3
F2
F1
D3
D1
J6
L6
J4
HDMI_0_RX0N
HDMI_0_RX0P
HDMI_0_RX1N
HDMI_0_RX1P
HDMI_0_RX2N
HDMI_0_RX2P
HDMI_0_CLKN
HDMI_0_CLKP
HDMI_0_SCL
HDMI_0_SDA
RXC0N
RXC0P
RXC1N
RXC1P
RXC2N
RXC2P
RXCCKN
RXCCKP
DDCDC_CK
DDCDC_DA
HOTPLUGC
AC8
AD9
AC9
AD10
AE10
AC10
AE8
AD8
AE7
AD7
AC7
SPDIFO
HDMI_0_RX1N
HDMI_0_RX0P
HDMI_0_RX0N
HDMI_0_CLKP
R1912
1k
R1910
1k
HDMI_0_SCL
HDMI_0_SDA
HDMI0_5V
HDMI0_HPD
CN707
HDMI1
R1874
10R
2
R1840
10k
R1835
10k
C1203
1
SC_R_OUT
10R
R1881
R1929
20k
100p
50V
R1927
82k
3V3_STBY
R1914
33k
C1180
SC_AUD_L_OUT
C1205
1 OUT1
VDD 8
2 IN1-
OUT2 7
3 IN1+
IN2- 6
4 VSS
IN2+ 5
TL062
V+
12V_VCC
R1913
33k
U178
1u
6V3
600R
100p
50V
R1926
82k
10u
10V
R1928
20k
C1202
2
SC_L_OUT
1u
6V3
V+
R1838
10k
470p
50V
C1189
1:NAND
R1839
10k
0:IPS
NC
1
2
C1178
R1890
4k7
SPDIF_OUT
NC
S92
100n
10V
R1907
100R
R1908
1k
2
1
NC
470p
50V
C1191
IPOD_AUDIO_IN_L
C1176
1
1
1
100n
10V
C1175
R1905
10k
2
3
1
D199
JK10
C5V6
F
IPOD_L_IN
Q202
BC848B
C1179
470p
50V
C1192
R1923
12k
50V
220p
50V
220p NC
IPOD_AUDIO_IN_R
R1889
4k7
470p
50V
R1906
10k
SAV_AUDIO_IN_L
C1190
IPOD_R_IN
SAV_AUDIO_IN_R
R1919
12k
R1904
10k
R1873
10R
1
R1836
10k
C1206
10u
10V
I2S_OUT_MCK
SAV_L_IN
HDMI1_5V
HDMI1_HPD
10R
R1875
F301
2
CFG_PWM1
470p
50V
C1188
R1920
12k
SCART_AUDIO_IN_L
R1903
10k
12V_VCC
100n
16V
SC_AUD_R_OUT
R1833
10k
R1901
10k
R1918
12k
SAV_R_IN
33k
R1916
C1177
C1181
CFG_PWM0
SC_AUD_L_IN
C1182
10u
10V
I2S_OUT_BCK
470p
50V
C1187
SCART_AUDIO_IN_R
R1921
12k
R1902
10k
V+
33k
R1915
I2S_OUT_SD
SC_AUD_R_IN
47k
R1863
47k
R1862
C1186
MODE SELECTION
AUDIO INPUTs
HDMI_1_SCL
HDMI_1_SDA
21
20
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
R1870
10R
10R
R1884 R1871
10R
10R
R1872 R1882
10R
10R
R1876 R1883
10R
HDMI_1_RX0N
HDMI_1_CLKP
CEC
DSP_SCART_R
10n
16V
HDMI_1_CLKN
CEC
R222
100R
10R
R1878
Q203
BC848B
HDMI_1_RX1N
HDMI_1_RX0P
SC_R_OUT
R1925
22k
HDMI0_HPD
HDMI_1_RX2N
HDMI_1_RX1P
R1888
10R
R1911
1k
HDMI_1_RX2P
R1917
10R
10R
R1885
HDMI_0_CLKN
CEC
Q204
BC848B
HDMI1_HPD
K5
CEC
R1909
1k
10n
16V
R223
100R
U157
MSD9WB7PX-2
RXB0N
RXB0P
RXB1N
RXB1P
RXB2N
RXB2P
RXBCKN
RXBCKP
DDCDB_CK
DDCDB_DA
HOTPLUGB
R1869
10R
10R
R1868 R1887
10R
10R
R1867 R1886
10R
10R
R1879 R1880
10R
C1185
R1924
22k
WAKEUP_ETH
SC_L_OUT
A6
B5
B6
C6
R1892I2S_OUT_MCK
4k7 I2S_OUT_SD
AUOUTL0
AUOUTR0
AUOUTL1
AUOUTR1
HDMI_0_RX2N
HDMI_0_RX1P
COMMON
V1
V2
AA6
Y5
HDMI_1_RX0N
HDMI_1_RX0P
HDMI_1_RX1N
HDMI_1_RX1P
HDMI_1_RX2N
HDMI_1_RX2P
HDMI_1_CLKN
HDMI_1_CLKP
HDMI_1_SCL
HDMI_1_SDA
21
20
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
47k
R1864
47k
R1865
C1168
DSP_MAIN_L
DSP_MAIN_R
DSP_SCART_L
DSP_SCART_R
G2
H3
H2
J3
J2
J1
G3
G1
M4
M5
K6
R1877
10R
33n
22K
RXA0N
RXA0P
RXA1N
RXA1P
RXA2N
RXA2P
RXACKN
RXACKP
DDCDA_CK
DDCDA_DA
HOTPLUGA
4k7
R1896
10V
10V
100R
AUL0
AUR0
AUL1
AUR1
AUL2
AUR2
AUL3
AUR3
10n
16V
C1184
R1898
4k7
DSP_MAIN_R
C1195
10u
10V
C1194
10u
10V
R4
R5
T6
U6
V6
U5
AD6
AC6
C1196
10u
10V
C1193
10u
10V
HDMI0_5V
4k7
R1897
MAIN_R
C1197
10u
C1198
10u
33n
SCART_AUDIO_IN_L
SCART_AUDIO_IN_R
SAV_AUDIO_IN_L
SAV_AUDIO_IN_R
IPOD_AUDIO_IN_L
IPOD_AUDIO_IN_R
4k7
R1895
100R
10n
16V
C1183
R1899
4k7
22K
HDMI_0_RX2P
DSP_MAIN_L
4k7
R1900
CN708
AUDIO OUTPUTs
MAIN_L
HDMI2
OPTIONAL
R1922
12k
DRAWN BY :MB60_HW_TEAM
88
A3
TOTAL SHEET:9
24-05-2011_13:43
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
VDD_AUDIO
HEADPHONE OUTPUT
1
F283
U163
12V_VCC
PT2333
TP230
60R
HP_L
TP229
SK24
F294
L_AUDIO_N_OUT
VDD_AUDIO
60R
10V
220u
C870
10V
220u
C615
35V
100u
C1208
5V_VCC
35V
100u
C1209
4
5
TP228
BC848B
Q192
BC848B
Q212
HP_DETECT
R1954
100R
C15V
OUTP
C3
SDB
C2
C1
INN
GNDB
B3
VDD1
1
VDD_AUDIO
CN710
AMP_EN
R_AUDIO_P_OUT
100n
10V
C608
R614
15k
C666
10V
100n
R_AUDIO_N_OUT
R1960
680R
R613
15k
100n
10V
HP_MUTE
Q211
BC848B
PT2333
B2
VDDA
B1
OUTN
A3
GNDA
INP
A2
C602
A1
BC848B
Q133
1
100n
10V
C617
VDD_AUDIO
3
MAIN_R
R1704
680R
BC848B
Q210
U164
3V3_VCC
VDD_AUDIO
4k7
R1149
W/2.5W opt.
JK6
D203
C665
100n
10V
AMP_EN
100n
10V
L_AUDIO_P_OUT
C1172 C729
10n
10n
16V
16V
60R
HP_R
R1855
10k
C3
C2
C1
B3
B2
B1
A3
R623
15k
D192
R1854
10k
OUTP
SDB
INN
GNDB
VDD1
VDDA
OUTN
INP
A2
18V_VCC
60R
R624
15k
R817
100R
24V_VCC
F284
A1
Q160
BC848B
C612
MAIN_L
GNDA
F285
R818
100R
CN140
R_AUDIO_P
R_AUDIO_N
L_AUDIO_P
L_AUDIO_N
4 R4 5
R1741
56R
100R
C1074
1u
25V
R1687
10k
C1073
1u
25V
MAIN_R
R1696
10k
C10761u
6V3
6V3
1u
C1078
U168
AGND
BSNR
GVDD
OUTNR
C1046
22
25V
220n
21 C1044
25V
220n
20
10
PLIMIT
PGND2
19
11
RINN
OUTPR
18
AVCC
BSNL
TPA3110D2
RINP
13
NC
PVCCR1
17 C1043220n
25V
16
14
PBTL
PVCCR2
15
BSPR
R1684
10k
10k
R1941
R1699
10k
D190
1N4148
2
2
2
R1702
10k
BC848B
Q185
D191
1N4148
3V3_VCC
R1712
15k
R616
10k
1
BC848B
Q186
R_AUDIO_N
600R
F297
R1309
10k
600R
F298
R_AUDIO_P_OUT
12
L_AUDIO_N
AMP_MUTE
R_AUDIO_N_OUT
Q195
BC858B
R1701
10k
F299
C1058
100n
16V
NC
100n
50V
L_AUDIO_N_OUT
NC
23
C1032
OUTNL
NC
R1718
100k
GAIN1
AMP_EN
600R
NC
3k9
R1711
PGND1
5V_VCC
GAIN0
24
1n
50V
25
L_AUDIO_P
1n
50V
OUTPL
F296
C942
LINN
L_AUDIO_P_OUT
C1045
220n
25V
C943
26
C1122
27
BSPL
S86
1n
50V
3 R3 6
ANALOG VCC
PVCCL1
LINP
S87
R_AUDIO_P
1n
50V
VDD_AUDIO
1u
50V
FAULT
10u
25V
600R
C944
2 R2 7
C1123
28
C945
VDD_AUDIO
NC100k
R1717
100k
R1716
1
8
R1
C1077
1u
6V3
C10751u
6V3
PVCCL2
VDD_AUDIO
12V_VCC
F281
60R
VDD_AUDIO
100n
50V
VDD_AUDIO
MAIN_L
SD
C1121
60R
3V3_STBY
F282
S85
100k
R1715
100k
R1714
NC
VDD_AUDIO
89
A3
TOTAL SHEET:9
24-05-2011_13:44
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
NAND_D4
NAND_CEz
NC25
40
10
NC7
NC24
39
11
NC8
NC23
38
12
VDD1
VDD2
37
13
VSS1
VSS2
36
14
NC9
NC22
35
15
CL
NC20
AL
I/O3
32
NAND_D3
I/O2
31
NAND_D2
19
WP
I/O1
30
NAND_D1
20
NC11
I/O0
29
NAND_D0
21
NC12
NC19
28
22
NC13
NC18
27
23
NC14
NC17
26
24
NC15
NC16
25
NC10
R1389
33R
R1 1
R2 2
R3 3
R4 4
NAND_D0 8
NAND_D1 7
NAND_D2 6
NAND_D3 5
R1398
33R
NAND_D4 8 R1 1
NAND_D5 7 R2 2
NAND_D6 6 R3 3
NAND_D7 5 R4 4
33
NAND_ALE 17
NAND_WPz
FLH_3.3V
NC21
NAND_CLE 16
R1495
3k9
NAND512-A
A3V3_VCC
34
NAND_WEz 18
FLH_3.3V
U162
USB_DP_ETH
PF_OEZ
R1388
33R
R1 1
R2 2
R3 3
R4 4
PF_AD15 8
PF_ALE 7
PF_CE1Z 6
PF_CE0Z 5
PCM_A0
PCM_A1
PCM_A2
PCM_A3
R1132
47R
R1133
47R
FLH_3.3V
NAND_REz S25
PCM_A4
PCM_A5
PCM_A6
PCM_A7
2
1
TP236
TP237
ETH_RXN
C889
100n
16V
1
2
TCT
C1116
33p
50V
ETH_RXP
NAND_WPz
NAND_ALE
NAND_CLE
NAND_CEz
X3
TD+
ETH_TXN
TP235
TP233
R1707
1M
CN711
1
TP234
C1068
100n
16V
A1V8_VCC
C890
100n
16V
ETH_TXP
R1134
47R
R1131
47R
NAND_CE2
USB_DM_ETH
33R
TD-
RD+
RCT
RD-
NC
GND
4
3
41MHz
25MHz
1V8_VCC_ETH
33
35
36
37
38
39
40
34
GND6
EECK
EECS
EEDIO
TCLK_1
TCLK_0
TCLK_EN
VCCK3
3V3_VCC
41
VCC3IO2
RST_ETH
42
RESET_N
43
TEST1
44
GPIO_0/PME
GND33A_H
GPIO_1
27
55
RREF
GPIO_2
26
56
DM
VCCK6
25
57
DP
EXTWAKEUP_N
24
58
VCC33A_PLL
GND2
23
59
GND33A_PLL
USB_LED
22
60
GND5
VCCK2
21
61
VCC18A2
LINK_LED
20
62
XTL25P
SPEED_LED
19
63
XTL25N
FDX_LED
18
64
GND18A1
VCC3IO1
17
C1117
33p
50V
U171
AX88772
C1067
100n
16V
A3V3_VCC
GND1
41
C1118
50V
1p
VCC33A_H
54
16
I/O4
C1069
100n
16V
R1763
12k
28
GND0
PF_WEZ
41MHz
12Mhz
29
15
33R
60R
SI_3
VCCK1
NAND_REz
NAND_WEz S5
3V3_VCC
XTL12N
53
14
NAND_D5
C1120
A3V3_VCC 15p
50V
C1072
100n
16V
F278
A1V8_VCC
C1059
100n
16V
52
VCCK0
NAND_D6
42
60R
A3V3_VCC
C1119
15p
50V
13
43
I/O5
F279
1V8_VCC
4
3
30
GND3R3
I/O6
RB
1
2
SI_2
12
NC6
C656
100n
10V
SDA_SYS
XTL12P
VCC3R3
NC
11
NAND_D7
VCC_PCMCIA
SCL_SYS
GND18A
44
C657
100n
10V
4k7
R1177
31
TXON
I/O7
TSMICLK
PCM_A12 C966
PCM_A7
PCM_A6
12p
PCM_A5
50V
PCM_A4
PCM_A3
PCM_A2
PCM_A1
PCM_A0
PCM_D0
PCM_D1
PCM_D2
32
NC5
P0_ETH
1V8_VCC_ETH
WAKEUP_ETH
1V8_VCC_ETH
3V3_VCC
C1055
100n
16V
C1050
100n
16V
3V3_VCC
C1054
100n
16V
C888
100n
16V
1V8_VCC_ETH
A3
VCC_PCMCIA
1V8_VCC
NC26
C868
22u
6V3
3V3_VCC
PCM_IRQA_N
TSMIVALID
C1052
100n
16V
ETH_TXN
NC4
45
60R
51
R1172
4k7
R1425
33R
SI_1
TXOP
46
X4
PCM_D3
PCM_D4
PCM_D5
PCM_D6
PCM_D7
PCM_CE_N
PCM_A10
PCM_OE_N
PCM_A11
PCM_A9
PCM_A8
PCM_A13
PCM_A14
PCM_WE_N
SI_0
ETH_TXP
NC27
FLH_3.3V
VCCK5
VCC18A1
NC3
R1642
10k
F187
3V3_VCC
VCC3IO3
50
A1V8_VCC
47
49
RXIN
NC28
1V8_VCC_ETH
C1057 C1063 C1065 C1056 C1066
100n 100n 100n 100n 100n
16V
16V
16V
16V
16V
NC2
60R
ETH_RXN
1V8_VCC
48
4
R1155
4k7
NC29
D7
S49
F_RBZ
NC1
3V3_VCC
C1053
100n
16V
1V8_VCC_ETH
TEST0
RF_AGC_CTL
SIF_CTL
TUN_SCL_MST
TUN_SDA_MST
F280
C906
33p
50V
IF_AGC_MST
RF_AGC_MST
45
AC4
AD2
AD4
AE4
PCM_REG_N
TSMOVALID
TSMOSTART
TS_MDO0
TS_MDO1
TS_MDO2
PCM_CD2_N
3V3_VCC
GPIO66
GPIO67
GPIO68
GPIO69
F268
PCM_RST
R1171
4k7
R1427
33R
46
AD3
AE3
330N
GND3
IF_AGC
RF_AGC
10V
100n
C913
L122
270n
5V_TUN
PCM_WAIT_N
DIGITAL_IF_N
GND4
SIFP
SIFM
3V3_VCC
RXIP
AB2
AB3
100N
330R
TSMOCLK C967
GND3A3
SIFP
SIFM
68pF
DIGITAL_IF_P
VIFP
VIFM
R196168pF
R1962
Q208
BC848B
33R
33R
CI_POWER_CTRL
R1953
4k7
ETH_RXP
Y3
Y2
TS_MDI4
TS_MDI5
TS_MDI6
TS_MDI7
30p
30p
VCC_PCMCIA
50V
12p
5V_VCC
R6
33R
R5
33R
C970
22u
6V3
R1950
4k7
R1951
4k7
12V_VCC
330N
VCC_PCMCIA
C653
100n
10V
L121
270n
C1
12pN.C.
50V
100N
R1548
33R
33R
R1547
V18F
C654
100n
10V
10
1V8_VCC_ETH
AA3
AA2
PCM_IORD_N
PCM_IOWR_N
TSMISYNC
TS_MDI0
TS_MDI1
TS_MDI2
TS_MDI3
Q209
BSH103
5V_VCC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
TS_MDO3
TS_MDO4
TS_MDO5
TS_MDO6
TS_MDO7
F304
50V
C15V
NAND_WPz
PCM_CD1_N
CN141
60R
NAND FLASH
FLH_3.3V
R1632
10k
3V3_VCC
47
R1942
33R
R1512
TSMICLK
33R
R1514
TS1_VALID 33R TSMIVALID
R1513
TS1_SYNC
33R TSMISYNC
TS1_CLK
VCCK4
F_RBZ
PF_ALE/NAND_ALE
PF_AD[15]/NAND_WPZ
PF_CE0Z/NAND_CEZ
PF_CE1Z/NAND_CLE
PF_OEZ/NAND_REZ
PF_WEZ/NAND_WEZ
F_RBZ/NAND_RBZ
CI INTERFACE
TSMOSTART
TSMOCLK
VCC3A3
PCM_WAIT_N
PCM_CE_N
PCM_OE_N
PCM_IRQA_N
T21
T19
P21
P20
R20
T20
P19
TS0_CLK
TSMOVALID
PF_ALE
PF_AD15
PF_CE0Z
PF_CE1Z
PF_OEZ
PF_WEZ
TS_MDO4
TS_MDO5
TS_MDO6
TS_MDO7
TS0_D0
TS0_D1
TS0_D2
TS0_D3
TS0_D4
TS0_D5
TS0_D6
TS0_D7
TS0_CLK
TS0_VALID C968
TS0_SYNC 12p
U20
V20
R19
AE13
AC13
Y11
AB11
AB13
Y19
Y23
W20
AB1
AA1
NAND_CE2
PCM_CD2_N
TS0_D4
TS0_D5
TS0_D6
TS0_D7
8
33R
R1384
5 R4 4
6 R3 3
7 R2 2
8 R1 1
33R
R1390
TS0_SYNC
R1673
4k7
33R
TS_MDI4
TS_MDI5
TS_MDI6
TS_MDI7
R1402
33R
R1401
33R
R1424
33R
TS0_VALID
48
U157
MSD9WB7PX-2
TS_MDO2
TS_MDO1
TS_MDO0
TS_MDO3
V_BUS
Y25
TS0_D2
R4
TS0_D1 4 R3 5
TS0_D0 3 R2 6
TS0_D3 2 R1 7
RSET_BG
3V3_VCC
PCM_IOWR_N
PCM_IORD_N
PCM_A13
PCM_WE_N
TS_MDI0
TS_MDI1
TS_MDI2
TS_MDI3
PCM_A7
PCM_A8
PCM_A11
PCM_A12
AD16
Y13
Y14
AA13
AC14
AB23
AB20
AB14
AA21
R4 4
R3 3
R2 2
R1 1
33R
R1383
5 R4 4
6 R3 3
7 R2 2
8 R1 1
33R
R1382
5
6
7
8
50V
P_IRQA_N
P_OE_N
P_IORD_N
P_CE_N
P_WE_N
P_CD2_N
P_WAIT_N
P_IOWR_N
P_REG_N
TS1_D0
TS1_D0
Y16
TS1_D1
TS1_D1
AD14
TS1_D2
TS1_D2
AD15
TS1_D3
TS1_D3
AC15
TS1_D4
AC16
TS1_D5
Y17
TS1_D6
TS1_D4
AB17
TS1_D7
TS1_D5
AB19
TS1_CLK TS1_D6
Y18
TS1_D7
AE16 TS1_VALID
AB16 TS1_SYNC
C969
12p
50V
R1762
12k
R4 4
R3 3
R2 2
R1 1
33R
R1399
5
6
7
8
PCM_A14
PCM_A10
PCM_A9
PCM_A5
Y24
Y22
AB22
AA22
AA20
Y21
AA18
AA19
AA16
AA14
AA12
Y15
AA17
AA15
AE14
Y20
TS1DATA[0]
TS1DATA[1]
TS1DATA[2]
TS1DATA[3]
TS1DATA[4]
TS1DATA[5]
TS1DATA[6]
TS1DATA[7]
TS1CLK
PCMADR[0]/CI_A[0]/PF_D[0] TS1VALID
PCMADR[1]/CI_A[1]/PF_D[1] TS1SYNC
PCMADR[2]/CI_A[2]/PF_D[2]
PCMADR[3]/CI_A[3]/PF_D[3]
PCMADR[4]/CI_A[4]/PF_D[4]
PCMADR[5]/CI_A[5]/PF_D[5]
PCMADR[6]/CI_A[6]/PF_D[6]
PCMADR[7]/CI_A[7]/PF_D[7]
TS0DATA[0]
PCMADR[8]/CI_A[8]
TS0DATA[1]
PCMADR[9]/CI_A[9]
TS0DATA[2]
PCMADR[10]/CI_A[10]
TS0DATA[3]
PCMADR[11]/CI_A[11]
TS0DATA[4]
PCMADR[12]/CI_A[12]
TS0DATA[5]
PCMADR[13]/CI_A[13]
TS0DATA[6]
PCMADR[14]/CI_A[14]
TS0DATA[7]
CI_RST
TS0CLK
TS0VALID
PCM_IRQ/CI_INT
TS0SYNC
PCMOEN
PCMIOR/CI_RD
PCMCEN/CI_CS
PCMWEN
PAD_PCM_CD_N
PCMWAIT/CI_WACK
IP
PCMIOW/CI_WR
IM
PCMREG/CI_CLK
QP
2
QM
GPIO125
VIFP
VIFM
A3V3_VCC
P_WAIT_N
P_CE_N
P_OE_N
P_IRQA_N
PCM_A2
PCM_REG_N
PCM_A3
PCM_RST
P_A0
P_A1
P_A2
P_A3
P_A4
P_A5
P_A6
P_A7
P_A8
P_A9
P_A10
P_A11
P_A12
P_A13
P_A14
P_RESET
PCMDATA[0]/CI_DATA[0]
PCMDATA[1]/CI_DATA[1]
PCMDATA[2]/CI_DATA[2]
PCMDATA[3]/CI_DATA[3]
PCMDATA[4]/CI_DATA[4]
PCMDATA[5]/CI_DATA[5]
PCMDATA[6]/CI_DATA[6]
PCMDATA[7]/CI_DATA[7]
C1060
100n
16V
PCM_A1
PCM_D3
PCM_D4
PCM_A4
W21
U21
U19
AD12
AC12
AD13
Y12
AA11
C905
R4 4
R3 3
R2 2
R1 1
33R
R1397
P_A1
5 R4 4
P_D3
6 R3 3
P_D4
7 R2 2
P_A4
8 R1 1
33R
R1395
P_A2
R4
P_REG_N 5 R3 4
6
3
P_A3
R2
P_RESET 7 R1 2
8
1
33R
R1392
P_A14
R4
P_A10 5 R3 4
P_A9 6 R2 3
7
2
P_A5
8 R1 1
33R
R1394
P_A7
5 R4 4
P_A8
R3
P_A11 6 R2 3
P_A12 7 R1 2
8
1
33R
R1396
P_IOWR_N R4
5
4
P_IORD_N
R3
P_A13 6 R2 3
P_WE_N 7 R1 2
8
1
33R
R1385
R1426
P_CD2_N
33R
5
6
7
8
PCM_D5
PCM_D6
PCM_D7
PCM_A6
P_D0
P_D1
P_D2
P_D3
P_D4
P_D5
P_D6
P_D7
33p
P_D5
P_D6
P_D7
P_A6
PCM_D1
PCM_D0
PCM_D2
PCM_A0
R4 4
R3 3
R2 2
R1 1
33R
R1393
5
6
7
8
R1660
4k7
R1173
4k7
P_D1
P_D0
P_D2
P_A0
R1529
4k7
3k9
R1496
90
24-05-2011_13:44
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
DDR18V
22R
AA_MCLKZ 56R
R1350
P7
A12
R2
BA0
L2
BA1
RAS_P
CAS_P
L3
K7
L7
WE_P
B9
CS_P
L8
B7
UDQS
CKE
K2
K3
AA_MADR3
BB_MDATA3
AA_MADR4
BB_MDATA4
AA_MADR5
BB_MDATA5
AA_MADR6
BB_MDATA6
AA_MADR7
BB_DDR2_DQS0
AA_MADR8
BB_DDR2_DQSB0
AA_MADR9
BB_DDR2_DQM0
AA_MADR10
BB_MDATA7
AA_MADR11
BB_MDATA8
AA_MADR12
BB_MDATA9
AA_BADR_BA0
BB_MDATA10
AA_BADR_BA1
BB_MDATA11
AA_RASZ
BB_MDATA12
AA_CASZ
BB_MDATA13
AA_WEZ
BB_MDATA14
BB_MDATA15
AA_MCLKE
BB_DDR2_DQS1
AA_MCLK
BB_DDR2_DQSB1
A9
C1
VDDQ1
C3
VDDQ2
C9
C7
VDDQ3
VDDQ4
E9
VDDQ5
G1
VDDQ6
G3
VDDQ7
G7
VDDQ9
VDDQ8
G9
A1
E1
VDD1
M9
J9
VDD2
VDDQ10
BB_MDATA2
G8
DQ0
A0
M8
G2
DQ1
A1
M3
H7
DQ2
A2
M7
H3
DQ3
A3
N2
H1
DQ4
A4
N8
H9
DQ5
A5
N3
F1
DQ6
A6
N7
F7
LQDS
A7
P2
E8
LQDS_P
A8
P8
F3
LDM
A9
P3
F9
DQ7
A10
M2
C8
DQ8
A11
P7
C2
DQ9
A12
R2
D7
DQ10
BA0
L2
D3
DQ11
BA1
L3
D1
DQ12
RAS_P
K7
D9
DQ13
CAS_P
L7
B1
DQ14
WE_P
K3
B9
DQ15
CS_P
L8
B7
UDQS
CKE
K2
A8
UDQS_P
CK
J8
B3
UDM
CK_P
K8
A2
NC1
ODT
K9
E2
NC2
VSS1
A3
HY5PS121621C
U154
M2
A11
AA_MADR2
VDD3
J1
A10
DQ8
BB_MDATA1
VDD5
VDDL
A9
C1
VDDQ1
C7
C9
C3
VDDQ2
VDDQ3
VDDQ4
G1
G3
G7
E9
VDDQ5
VDDQ6
VDDQ7
VDDQ8
G9
DQ7
AA_MADR1
VSS1
A3
L1
NC3
VSS2
E3
L1
NC3
VSS2
E3
R3
NC4
VSS3
J3
R3
NC4
VSS3
J3
R7
NC5
VSS4
N1
R7
NC5
VSS4
N1
AA_MADR13
R8
NC6
VSS5
P9
R8
NC6
VSS5
P9
COMMON
C689
100n
10V
BB_MADR1
BB_MADR2
BB_MADR3
BB_MADR4
BB_MADR5
BB_MADR6
BB_MADR7
BB_MADR8
BB_MADR9
BB_MADR10
BB_MADR11
BB_MADR12
BB_BADR_BA0
BB_BADR_BA1
BB_RASZ
BB_CASZ
BB_WEZ
C
BB_MCLKE
BB_MCLK
BB_MCLKZ
BB_ODT
VSSQ1
OPTIONAL
F181
DDR18V
2
C709
100n
10V
C782
22u
16V
C710
100n
10V
C712
100n
10V
D1
60R
1V8_VCC
AA_MCLK
A_MCLKZ
R1313
A_DDR2_DQM022R 56R
AA_DDR2_DQM1
AA_DDR2_DQM0
22R 56R
AA_DDR2_DQS0
A_DDR2_DQS0
R1333
R1331
A_DDR2_DQSB0
AA_DDR2_DQSB0
22R 56R
R1335
A_DDR2_DQS122R 56R
AA_DDR2_DQS1
R1330
A_DDR2_DQSB1
AA_DDR2_DQSB1
22R 56R
BB_MDATA15
BB_MDATA8
BB_MDATA10
BB_MDATA13
B_MDATA7 22R
4
B_MDATA0
3
B_MDATA2
2
B_MDATA5
BB_MDATA7
BB_MDATA0
BB_MDATA2
BB_MDATA5
B_MADR4 22R
4
B_MADR6
3
B_MADR8
2
B_MADR11
BB_MADR4
BB_MADR6
BB_MADR8
BB_MADR11
R4 5
R3 6
R2 7
1 R1 8
56R
R1378
R4 5
R3 6
R2 7
1 R1 8
56R
R1374
B_WEZ
B_MCLKE
B_BADR_BA1
B_BADR_BA0
R1327
B_DDR2_DQM122R 56R
R1319
B_DDR2_DQM022R 56R
BB_DDR2_DQM1
BB_DDR2_DQM0
TP14
1N4148
NC
2
SPI_CSN_1
SPI_SDO
FLASH_WPN
SPI_SDI_1
R1323
B_DDR2_DQS022R 56R BB_DDR2_DQS0
R1321
B_DDR2_DQSB022R 56R BB_DDR2_DQSB0
R1325
B_DDR2_DQS122R 56R BB_DDR2_DQS1
R1317
B_DDR2_DQSB122R 56R BB_DDR2_DQSB1
D165
F172
R4 5
R3 6
R2 7
1 R1 8
56R
R1377
SERIAL FLASH
3V3_STBY
R4 5
R3 6
R2 7
R1 8
56R
R1379
100R
4
3
2
1
U158
MX25L512
SPI_SDI
1
2
3
4
CS#
SO
WP#
GND
VCC
HOLD#
SCLK
SI
8
7
6
5
R1248
100R
SPI_SCK
SPI_SDI
91
3V3_STBY
330R
C658
100n
10V
TP12
AA_WEZ
AA_MCLKE
AA_BADR_BA1
AA_BADR_BA0
B_MDATA1522R
4
B_MDATA8
B_MDATA10 3
B_MDATA13 2
R1346
BB_ODT
22R 56R
R1612
56R
BB_WEZ
22R1 R1 8
BB_MCLKE
2 R2 7
3 R3 6 BB_BADR_BA1
4 R4 5 BB_BADR_BA0
AA_MADR2
AA_MADR0
AA_CASZ
AA_RASZ
AA_ODT
E
B_ODT
R1183
4k7
R1603
22R 56R
R1613
56R
A_WEZ
22R1 R1 8
A_MCLKE
2 R2 7
A_BADR_BA1 3 R3 6
A_BADR_BA0 4 R4 5
A_ODT
BB_MDATA6
BB_MDATA1
BB_MDATA3
BB_MDATA4
TP11
R1371
56R
R1 8
R2 7
R3 6
R4 5
B_MDATA6 22R1
B_MDATA1
2
B_MDATA3
3
B_MDATA4
4
A3
TOTAL SHEET:9
DRAWN BY :MB60_HW_TEAM
BB_MADR0
A7
B2
B8
D2
D8
E7
F2
F8
1k
R1363
VSSQ9
DDR18V
C15V
C687
100n
10V
BB_MADR13
R1355
1k
BB_BADR_BA2
H2
J2
1k
R1364
150R
R1943
VSSQ2
E2
NC2
AA_ODT
VSSQ3
K9
VSSQ4
ODT
VSSQ5
NC1
BB_DDR2_DQM1
AA_MCLKZ
VSSQ6
K8
A2
J8
VSSQ7
CK_P
VSSQ8
B3
UDM
CK
VSSQ10
A8
AA_DDR2_DQM1
AA_BADR_BA2
R1332
A_MCLK
VDDQ9
P3
BB_MDATA0
UDQS_P
MVREF
A_DDR2_DQM122R 56R
R1314
22R 56R
A1
A9
AA_MADR0
AA_MADR4
AA_MADR6
AA_MADR8
AA_MADR11
R1368
56R
R1 8
R2 7
R3 6
R4 5
A_MADR2 22R1
A_MADR0
2
A_CASZ
3
A_RASZ
4
DDR18V
AA_MDATA15
AA_MDATA8
AA_MDATA10
AA_MDATA13
C717
100n
10V
TP41
R4 5
R3 6
R2 7
1 R1 8
56R
R1366
A_MADR4 22R R4
4
5
A_MADR6
3 R3 6
A_MADR8
2 R2 7
A_MADR11
1 R1 8
56R
R1609
AA_MADR12
AA_MADR7
AA_MADR9
AA_MADR3
R4 5
R3 6
R2 7
1 R1 8
56R
R1370
TP15
TP40
A_MDATA1522R
4
A_MDATA8
A_MDATA10 3
A_MDATA13 2
AA_MDATA6
AA_MDATA1
AA_MDATA3
AA_MDATA4
A_MADR12 22R
4
A_MADR7
3
A_MADR9
2
A_MADR3
VDDQ10
LDM
DQ15
AA_MADR5
AA_MADR10
AA_MADR1
AA_BADR_BA2
R4 5
R3 6
R2 7
1 R1 8
56R
R1380
E1
P8
DQ14
AA_MADR13
A_MADR5 22R
4
A_MADR10
3
A_MADR1
A_BADR_BA2 2
A_MDATA6
A_MDATA1
A_MDATA3
A_MDATA4
R1610
56R
1 R1 8
2 R2 7
3 R3 6
4 R4 5
AA_MDATA7
AA_MDATA0
AA_MDATA2
AA_MDATA5
R1602
C720
100n
10V
AA_MDATA11
AA_MDATA12
AA_MDATA9
AA_MDATA14
J9
A8
VREF
A_MDATA7
A_MDATA0
A_MDATA2
A_MDATA5
R4 5
R3 6
R2 7
1 R1 8
56R
R1367
22R R4
4
5
3 R3 6
2 R2 7
R1
1
8
56R
R1369
VDD1
VDD5
P2
LQDS_P
B1
DDR18V
A_MDATA1122R
A_MDATA12 4
3
A_MDATA9
A_MDATA14 2
AA_DDR2_DQSB1
MVREF
MVREF D22
H8
C683
100n
10V
C719
100n
10V
VSSDL
A7
DQ13
J7
1k
R1365
D9
R1944
150R
AA_DDR2_DQS1
LQDS
DQ12
C722
100n
10V
VREF
B_WEZ
R25
B_RASZ
F23
B_CASZ
E24
T24 B_BADR_BA0
T25 B_BADR_BA1
B_BADR_BA2
U23
B_ODT
F24
AA_MDATA15
D1
J2
B_WEZ
B_RASZ
B_CASZ
B_BADR[0]
B_BADR[1]
B_BADR[2]
B_ODT
AVDD_DDR
AA_MDATA14
N7
DQ11
R1357
1k
R1358
1k
U157
B_MCLKE
AA_MDATA13
N3
A6
DQ10
C721
100n
10V
R1354
1k
R4 5
R3 6
R2 7
1 R1 8
56R
R1375
BB_MDATA11
BB_MDATA12
BB_MDATA9
BB_MDATA14
N8
A5
D7
D3
N2
DQ6
DQ9
VSSQ1
B_MDATA1122R
B_MDATA12 4
3
B_MDATA9
B_MDATA14 2
B_MCLK
B_MCLKZ
MSD9WB7PX-2
AA_MDATA12
A4
M7
DQ5
C2
A7
A_WEZ
A_RASZ
A_CASZ
A_BADR[0]
A_BADR[1]
A_BADR[2]
A_ODT
AA_MDATA11
DQ4
VSSQ2
B20
B10
A10
A21
B21
C22
C11
BB_MCLKZ
AA_MDATA10
BB_MCLK
A3
B2
A_WEZ
A_RASZ
A_CASZ
A_BADR_BA0
A_BADR_BA1
A_BADR_BA2
A_ODT
R1315
B_MCLKZ22R 56R
DQ3
VSSQ3
A_MCLKE
R1349
B_MCLK22R 56R
A2
B8
C12 A_MCLK
B11 A_MCLKZ
C21 A_MCLKE
AA_MDATA9
DQ2
VSSQ4
A_MCLK
A_MCLKZ
H7
BB_MADR5
R4 5
BB_MADR10
AA_MDATA3
R3 6
H3
BB_MADR1
R2 7
BB_BADR_BA2
AA_MDATA4
H1
1 R1 8
56R
AA_MDATA5
R1373
H9
B_MADR12 22R R4
BB_MADR12
4
5
B_MADR7
AA_MDATA6
BB_MADR7
F1
3 R3 6
B_MADR9
BB_MADR9
2 R2 7
B_MADR3
BB_MADR3 AA_DDR2_DQS0
F7
1 R1 8
56R
AA_DDR2_DQSB0
R1611
E8
R1608
AA_DDR2_DQM0
56R
F3
B_MADR2 22R1 R1 8
BB_MADR2
B_MADR0
BB_MADR0
AA_MDATA7
2 R2 7
F9
BB_CASZ
B_CASZ
3 R3 6
AA_MDATA8
BB_RASZ
B_RASZ
4 R4 5
C8
D2
M3
VSSQ5
B_DQS[0]
B_DQSB[0]
B_DQS[1]
B_DQSB[1]
L24 B_DDR2_DQS0
L23 B_DDR2_DQSB0
K24 B_DDR2_DQS1
K25 B_DDR2_DQSB1
M8
A1
D8
A_DQS[0]
A_DQSB[0]
A_DQS[1]
A_DQSB[1]
A0
DQ1
VSSQ6
B_MDATA0
B_MDATA1
B_MDATA2
B_MDATA3
B_MDATA4
B_MDATA5
B_MDATA6
B_MDATA7
B_MDATA8
B_MDATA9
B_MDATA10
B_MDATA11
B_MDATA12
B_MDATA13
B_MDATA14
B_MDATA15
DQ0
G2
AA_MDATA2
B_MADR5 22R
4
B_MADR10
3
B_MADR1
B_BADR_BA2 2
C723
100n
10V
G8
E7
A_DDR2_DQS0 A16
A_DDR2_DQSB0 C16
A_DDR2_DQS1 A15
A_DDR2_DQSB1 B15
B_MDATA[0]
B_MDATA[1]
B_MDATA[2]
B_MDATA[3]
B_MDATA[4]
B_MDATA[5]
B_MDATA[6]
B_MDATA[7]
B_MDATA[8]
B_MDATA[9]
B_MDATA[10]
B_MDATA[11]
B_MDATA[12]
B_MDATA[13]
B_MDATA[14]
B_MDATA[15]
H23
P24
G24
R23
R24
G25
P23
H24
J25
N23
J24
N24
N25
J23
M25
K23
AA_MDATA1
R1328
B_MADR13 22R 56R BB_MADR13
HY5PS121621C
U155
A_MDATA[0]
A_MDATA[1]
A_MDATA[2]
A_MDATA[3]
A_MDATA[4]
A_MDATA[5]
A_MDAT[6]
A_MDATA[7]
A_MDATA[8]
A_MDATA[9]
A_MDATA[10]
A_MDATA[11]
A_MDATA[12]
A_MDATA[13]
A_MDATA[14]
A_MDATA[15]
B_MADR0
B_MADR1
B_MADR2
B_MADR3
B_MADR4
B_MADR5
B_MADR6
B_MADR7
B_MADR8
B_MADR9
B_MADR10
B_MADR11
B_MADR12
B_MADR13
VSSQ7
C13
A19
A12
B19
C20
B12
C19
A13
B14
C18
C14
A18
B18
B13
B17
C15
E23
U24
D24
V25
D25
V24
D23
W25
C25
W24
V23
C24
W23
B25
F2
A_MDATA0
A_MDATA1
A_MDATA2
A_MDATA3
A_MDATA4
A_MDATA5
A_MDATA6
A_MDATA7
A_MDATA8
A_MDATA9
A_MDATA10
A_MDATA11
A_MDATA12
A_MDATA13
A_MDATA14
A_MDATA15
B_MADR[0]
B_MADR[1]
B_MADR[2]
B_MADR[3]
B_MADR[4]
B_MADR[5]
B_MADR[6]
B_MADR[7]
B_MADR[8]
B_MADR[9]
B_MADR[10]
B_MADR[11]
B_MADR[12]
B_MADR[13]
VSSQ8
A_MADR[0]
A_MADR[1]
A_MADR[2]
A_MADR[3]
A_MADR[4]
A_MADR[5]
A_MADR[6]
A_MADR[7]
A_MADR[8]
A_MADR[9]
A_MADR[10]
A_MADR[11]
A_MADR[12]
A_MADR[13]
F8
C10
A22
A9
B23
B9
A23
C9
C23
B8
A24
B22
C8
B24
B7
VSSQ9
A_MADR0
A_MADR1
A_MADR2
A_MADR3
A_MADR4
A_MADR5
A_MADR6
A_MADR7
A_MADR8
A_MADR9
A_MADR10
A_MADR11
A_MADR12
A_MADR13
AA_MDATA0
H2
VDDL
VDD2
C713
100n
10V
VSSQ10
H8
C711
100n
10V
M9
VDD3
C716
100n
10V
VSSDL
J7
C714
100n
10V
VDD4
J1
C715
100n
10V
R1
C718
100n
10V
R1
VDD4
DDR18V
DDR18V
R1356
1k
24-05-2011_13:45
AX M
12V_VCC
1
4
12
PIN_7_8
14
PIN_10
16
1
8
7
10
9
13
18
17
20
19
22
21
24
23
26
25
28
27
A/D DIMMING SELECTION
NC
R2
3V3_VCC
4k7
1
PL1
15
PIN_7_8
STBY_ON/OFF
1
600R
2
PL3
MEGA_DCR_IN
24V_VCC
PL2
PL4
PANEL_VCC_ON/OFF
BACKLIGHT_DIM
3V3_VCC
1
3V3_VCC
1
11
5V_VCC
1
PIN_9
12V_VCC
1
PIN_11
DIMMING
BACKLIGHT_ON/OFF
W/IPS16
S95
NC
4
S82
R1685
10k
1
1
5V_VCC
NC
18V_VCC
PIN_7_8
DIMMING
STBY_ON/OFF
MEGA_DCR_OUT
S16
1
S18
NC
2
2
2
3
R1165
4k7
C838
F289
2
60R
2
220p
50V
F302
2
60R
F290
60R
MECH_SWITCH
R1693
10k
C1042
100n
Q194
10V
BC848B
1
R1725
47R
S29
NC
NC
2
1
R1158
4k7
R1166
4k7
92
2
2
C839
C840
Q193
BC858B
220p
50V
Q189
BC848B
3
F288
60R
2
VOUT
4
4k7
R1676
W/IPS16
1
NC
STBY_ON/OFF_NOT
DIMMING CIRCUIT
7 R2 2
1
6 R3 3
Q188
BC848B
R1679
4k7
2
5 R4 4
C774
10u
10V
220p
50V
1
1
6
2
Q180
BC858B
2
1
R1638
10k
Q178
R1748
4k7
R1761
100R
8
1
R1
3
R1635
10k
R1636
10k
D185
BAW56
R13
910R
5V_STBY
OUT 2
1
1
3
D186
BAW56
1
ADJ
2
BACKLIGHT_ON/OFF
3 IN
3
NC
3V3_STBY
2
AVDD_DDR
VDD_3V3
AVDD_3V3
AVDD_ALIVE_0
AVDD_ALIVE_1
AVDD_ALIVE_2
AVDD_ALIVE_3
AVDD_ALIVE_4
PGA_COM
AVDD_PGA25
AVDD_MOD25_0
AVDD_MOD25_1
AVDD_AU25
AVDD_REF25_0
AVDD_REF25_1
AVDD_ADC25_0
AVDD_ADC25_1
AVDD_EAR33
AVDD_AU33
AVDD_DDR_0
AVDD_DDR_1
AVDD_DDR_2
AVDD_DDR_3
AVDD_DDR_4
AVDD_DDR_5
AVDD_DDR_6
AVDD_DDR_7
AVDD_DDR_8
AVDD_DDR_9
N19
M19
L19
K19
N20
M20
L20
K20
N21
M21
L21
K21
N22
M22
L22
K22
J22
H22
U18
T18
R18
P18
N18
M18
L18
K18
GND3
GND4
GND5
GND6
GND7
GND8
GND9
GND10
GND11
GND12
GND13
GND14
GND15
GND16
GND17
GND18
GND19
GND20
GND21
GND22
GND23
GND24
GND25
GND26
GND27
GND28
L10 BYPASS
E17
E18
F17
F18
G17
G16
H16
H17
J16
J17
U157
MSD9WB7PX-2
G18 AVDD_LPLL
E19 VDDP0
F19 VDDP1
J9
K9
H9 AVDD_CVBS33_0
H10 AVDD_CVBS33_1
G10 AVDD_DMPLL
E9
E10
F9
F10
G9
U8
T8
P8
P9
R9
N8
N9
M8
M9
J21 AVDD126
GND29
GND30
GND31
GND32
GND33
GND34
GND35
GND36
GND37
GND38
GND39
GND40
GND41
GND42
GND43
GND44
GND45
GND46
GND47
GND48
GND49
GND50
GND51
GND52
GND53
GND54
GND55
GND56
GND57
GND58
GND59
GND60
GND61
GND62
GND63
GND64
GND65
GND66
GND67
GND68
GND69
GND70
GND71
GND72
GND73
GND74
GND75
GND76
GND77
GND78
GND79
GND80
GND81
GND82
GND83
GND84
GND85
GND86
GND87
GND88
GND89
GND90
GND91
GND92
GND93
GND94
GND95
GND96
GND97
GND98
GND99
GND100
GND101
GND102
GND103
GND104
GND105
GND106
GND107
GND108
GND109
GND110
GND111
GND112
GND113
GND114
GND115
GND116
GND117
GND118
GND119
GND120
GND121
GND122
GND123
GND124
GND125
GND126
GND127
GND128
GND129
GND130
GND131
GND132
GND133
GND134
GND135
GND136
GND137
AC2
AE1
Y10
V7
W7
V8
W8
V9
W9
J10
K10
M10
N10
P10
R10
T10
U10
V10
W10
D11
G11
H11
J11
K11
L11
M11
N11
P11
R11
T11
U11
V11
W11
D12
E12
F12
G12
H12
J12
K12
L12
M12
N12
P12
R12
T12
U12
V12
W12
D13
E13
F13
H13
J13
K13
L13
M13
N13
P13
R13
T13
U13
D14
E14
F14
G14
H14
J14
K14
L14
M14
N14
P14
R14
T14
U14
D15
E15
F15
G15
H15
J15
K15
L15
M15
N15
P15
R15
T15
U15
U16
T16
R16
P16
N16
M16
L16
K16
F16
E16
D16
K17
L17
M17
N17
P17
R17
T17
U17
2
3
D184
BAW56
4
S20
PIN_7_8
W/PW26
H20 DVDD_DDR0
J20 DVDD_DDR1
F271
R1639
10k
6
PIN_10
12V_VCC
PIN_11
7
W/IPS16
S21
PROTECT
8
W/PW26
5V_STBY
TP202
10
S23
W/IPS16
12V_VCC
5V_VCC
TP213
PIN_9
PIN_9
PIN_11
S22
11
W/IPS16
S8
FDC642P
Q199
12
S1
12V_STBY
PIN_10
3V3_VCC
2
PIN_7_8
VDD_3V3
C1029 C1014
10u
100n
6V3
16V
5V_VCC
CN1
3V3_VCC
S24
CN706
2
PIN_7_8
R1221
1k
S7
STBY_INFO
13
F270
E
S91
15
14
F275
KEYBOARD_ONBOARD
16
60R
VDDC0
VDDC1
VDDC2
VDDC3
VDDC4
VDDC5
VDDC6
VDDC7
VDDC8
VDDC9
AVSS_PGA
AVSS_PGA
AVDD_DDR
AVDD_2V5_PGA
F272
33k
R1734
NC
17
3V3_VCC
AVDD_2V5_PGA
AVDD_2V5
C1007
100n
16V
R1749
22k
D
19
18
60R
C1128
PIN_7_8
C1008
100n
16V
F274
25V
470n
5V_VCC
20
VDDC_1V2
C1070
100n
16V
AVDD_2V5
3V3_VCC
C1028 C1009
10u
100n
6V3
16V
60R
AVDD_3V3
C1022
100n
16V
2V5_VCC
VDDC_1V2
60R
C1025
100n
16V
4k7
R1678
C
2
2V5_VCC
C1030 C1024
100n
10u
16V
6V3
C1005
100n
16V
S17
B
60R
C997
100n
16V
E22
F22
E21
F21
G21
H21
E20
F20
G20
G22
60R
1V8_VCC
C1081
10u
6V3
F295
3V3_STBY
SOFT_SW
SOFT_SW
A
60R
C5
22u
16V
1V2_VCC
C7
22u
16V
C6
22u
16V
LC-32SH130E
LC-32SH130K
LC-32SH340E
F277
R14
560R
1
2
2
5V_STBY
R1677
4k7
1
2
DIMMING
3V3_STBY
1
10k
R1688
R1649
33k
10k
R1631
R1727
33k
R1750
22k
DRAWN BY :MB60_HW_TEAM
1u
6V3
C974
W/PW26
3V3_STBY
STBY_ON/OFF
Q191
BC848B
W/PW26
24V_VCC
12V_VCC
3V3_VCC
5V_VCC
5V_TUN
BC848B
1
F250
2
Q190
BC848B
TOTAL SHEET:9
A3
24-05-2011_13:45
AX M
R1737
33k
L118
D197
4
DIMMING
5n6
50V
C1130
TP243
1
4
25V
R1722
47R
12V_VCC
DC-DC4
DC
FDC642P
Q198
12V_STBY
1V2_VCC
DC-DC1
DC
5V_STBY
DC
DC
SW2
5V_VCC
DC-DC2
3V3_STBY
DC
DC
5V_STBY
C1103
22u
16V
15u
C1102
22u
16V
SS33
MOSFET_CONTROL
R1698
10k
SW3
3V3_VCC
Q184
BC848B
DC-DC3
DC
1V8_VCC
DC
DIMMING
BACKLIGHT_ON/OFF
R1709
3k9
0R
12V_INV
9.1K
CN705
12V_INV
R1690
10k
5V_VCC
LDO
SW1
8
7
6
5
SS
EN
COMP
FB
7A/32VDC
R1729
33k
60R
C1091
22u
16V
LDO2
8V
LDO
5V_VCC
5V_STBY
1 BS
2 IN
3 SW
C1092 C1037
4 GND
22u
100n
16V
10V
F287
1
12V_STBY
12V_INV
SW2
C1038
100n
10V
LDO2
U174
MP1583
R1728
33k
FS2
1
C1112
10n
16V
7A/32VDC
12V_STBY
DC/DC1
FS3
1
4
JK9
220n
C1047
TP211
TP239
W_ADAPTER
W/ADAPTOR
ADAPTER SOCKET
LDO1
BACKLIGHT_ON/OFF
2V5_VCC
LDO
Q182
BC848B
3V3_VCC
FDC642P
Q197
R1723
47R
SS33
15u
C1096
22u
16V
R1730
33k
2
3
3V3_STBY
R1697
10k
MOSFET_CONTROL
Q183
BC848B
C1097
22u
16V
STBY_ON/OFF_NOT
60R
C1094
22u
16V
C1093
22u
16V
C1085
22u
16V
C1084
22u
16V
1V8_VCC
15u
C1101
22u
16V
2 IN
U173
3 SW
4 GND
C1098
22u
16V
COMP 6
FB 5
12K
NC
10UH
L117
15u
S83
EN 7
MP1484
MOSFET_CONTROL
C1087
22u
16V
R1958
330R
C1213
100n
10V
8V_VCC
R1957
1k
C1214
16V
100u
R1691
12V_VCC
10k
C1131 R1710
3k9
R1686
5n6
10k
50V
R1768
33K
1k8
0R
2
C1035
100n
10V
1
60R
VOUT
LDO 2
F300
8V_VCC
330R
U180
LM1117
3 IN
OUT 2
GND
1
VOUT
4
TP240
SW 3
SS 8
GND
4 PVIN
MP2012
10UH
L116
F273
12V_VCC
330R
C1079
GND 2
TP241
5 VIN
R1770
510k
150K
1 BS
TP231
60R
F292
FB 1
12V_VCC
R1956
330R
S89
5V_VCC
U176
U181
LM1117
3 IN
OUT 2
F305
1
C1212
22u
16V
C1034
100n
10V
5V_TUN
R1955
1k
STBY_ON/OFF
100R
R1720
3V3_VCC
6 EN
C1113
10n
16V
R1736
33k
F291
100K
R1769
390k
2V5_VCC
C1033
22u
16V
3V3_STBY
OUT 2
VOUT
GND
R1738
18k
20K
10V
100n
C1107
3 IN
60R
U175
LM1117
F276
3V3_VCC
DC/DC3
TP232
LDO1
60R
R1721
100R
5V_VCC
100u
F303
DC/DC4
16V
100u
COMMON
TP251
D202
TP244
15u
L16 10UH
2
R1692
10k
R1735
33k
R1733
33k
2
MOSFET_CONTROL
4
1
FB 5
7A/32VDC
4 GND
R1731
33k
COMP 6
R1689
12V_STBY
10k
C1129
R1708
5K6
3k9
3N3
R3
5n6
10k
50V
3 SW
EN 7
MP1484
C1090
22u
16V
C
FS4
3V3_STBY
220n
25V
2 IN
SS 8
C1048
C1089
22u
16V
U23
60R
R1724
47R
F286
1
12V_STBY
1 BS
C1114
10n
16V
C1036
100n
10V
12V_VCC
SW3
R1732
33k
2
1
220n
25V
C1049
7A/32VDC
FDC642P
Q200
12V_STBY
DC/DC2
TP238
FS5
SW1
6V3
C1080
LC-32SH130E
LC-32SH130K
LC-32SH340E
1V2_VCC
C1086
22u
16V
93
A3
TOTAL SHEET:9
24-05-2011_13:45
AX M
LC-32SH130E
LC-32SH130K
LC-32SH340E
94
10
11
12
13
14
15
16
LC-32SH130E
LC-32SH130K
LC-32SH340E
95
LC-32SH130E
LC-32SH130K
LC-32SH340E
Note:
96
LC-32SH130E
LC-32SH130K
LC-32SH340E
PARTS LISTING
REPLACEMENT
PARTS
REPLACEMENT PARTS
Replacement parts
which
havehave
special
safety safety
characteristics
are identified
this manual.
Replacement
parts
which
special
characteristics
areinidentified
in this
Electrical components having such features are identified by in the Replacement Parts Listing.
manual.
Electrical components having such features are identified by ! in the ReplaceThe use of a substitute replacement part which does not have the same safety characteristics
ment
Parts Listing.
as the factory recommended is not permitted.
Replacement parts not shown in this service manual may create shock fire, or other hazards.
The use of a substitute replacement part which does not have the same safety
characteristics as theHOW
factory
is not permitted.
TO recommended
ORDER REPLACEMENT
PARTS
Replacement parts not shown in this service manual may create shock fire, or
other
hazards.
To have your order completed promptly and correctly please supply the following information.
1. MODEL NUMBER
4. DESCRIPTION
2. REF. NO.
5. CODE
3. PART NO.
6. QUANTITY
To have your order completed promptly and correctly please supply the
following information.
1. MODEL NUMBER
2. REF. NO.
3. PART NO.
4
5. CODE
6. QUANTITY
. DESCRIPTION
DELIVERY SECTION
DESCRIPTION
PRICE
CODE
NOTE : THE PARTS HERE SHOWN ARE SUPPLIED AS AN ASSEMBLY BUT NOT INDEPENDENTLY
30067866 TFT LCD 32"W LG LC320WXN-SCB1 (PL)RoHS (SH130)
---
U149
U155
U157
U158
U162
U168
U173
U175
U176
U178
U180
U181
U3
PRICE
CODE
--
Q178
--
Q180
--
Q181
--
Q185
--
Q186
--
Q188
--
Q189
--
Q190
--
Q191
--
Q192
--
Q193
--
Q194
--
Q195
--
Q199
--
Q202
--
Q203
--
Q204
--
Q205
--
Q207
--
Q208
--
Q209
--
Q210
--
D145
DIODES
-------
MB60
MAIN Unit
INTEGRATED CIRCUITS
U145
Q174
DESCRIPTION
---------------
--
D165
--
D169
--
D171
--
D173
--
D174
--
D175
--
D176
--
D177
--
D178
--
D184
--
D185
--
D186
--
D189
--
D191
--
D192
--
D2
--
D203
--
D204
--
D7
--
X2
--
L104
PACKAGED CIRCUITS
COILS AND FILTERS
TRANSISTORS
--
Q119
--
L114
--
Q140
--
L115
--
Q144
--
L116
--
Q146
--
L117
--
Q170
--
L119
--
Q171
--
L120
--
Q173
--
L124
--
97
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
F179
--
C1034
--
F181
--
C1035
--
F187
--
C1042
--
F200
--
C1043
--
F201
--
C1044
--
F202
--
C1045
--
F203
--
C1046
--
F205
--
C1058
--
F206
--
C1070
--
F248
--
C1073
--
F249
--
C1074
--
F259
--
C1075
--
F261
--
C1076
--
F266
--
C1077
--
F268
--
C1078
--
F270
--
C1079
--
F271
--
C1080
--
F272
--
C1081
--
F273
--
C1084
--
F274
--
C1085
--
F275
--
C1086
--
F277
--
C1087
--
F281
--
C1093
--
F282
--
C1094
--
F291
--
C1098
--
F295
--
C1101
--
F296
--
C1107
--
F297
--
C1113
--
F298
--
C1121
--
F299
--
C1122
--
F300
--
C1123
--
F301
--
C1131
--
F303
--
C1168
--
F305
--
C1169
--
C1170
--
C1171
--
C1172
--
C1174
--
TUNER
TU102
--
CAPACITORS
C1004
--
C1175
--
C1001
--
C1176
--
C1004
--
C1177
--
C1005
--
C1178
--
--
C1007
--
C1179
C1008
--
C1180
--
C1009
--
C1181
--
C1014
--
C1182
--
C1015
--
C1183
--
C1016
--
C1184
--
C1022
--
C1185
--
C1024
--
C1186
--
C1025
--
C1187
--
C1028
--
C1188
--
C1029
--
C1189
--
C1030
--
C1190
--
C1031
--
C1195
--
C1032
--
C1196
--
C1033
--
C1197
--
98
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
C1198
--
C804
--
C1199
--
C805
--
C120
--
C806
--
C1200
--
C807
--
C1201
--
C808
--
C1202
--
C809
--
C1203
--
C810
--
C1205
--
C823
--
C1206
--
C828
--
C1208
--
C829
--
C1209
--
C830
--
C1210
--
C831
--
C1212
--
C832
--
C1213
--
C833
--
C1214
--
C835
--
C135
--
C836
--
C14
--
C838
--
C143
--
C839
--
C2
--
C840
--
C3
--
C853
--
C378
--
C854
--
C5
--
C855
--
C545
--
C856
--
C546
--
C857
--
C547
--
C858
--
C6
--
C859
--
C610
--
C860
--
C630
--
C861
--
C653
--
C862
--
C654
--
C868
--
C656
--
C881
--
C657
--
C882
--
C658
--
C883
--
C663
--
C884
--
C664
--
C885
--
C683
--
C886
--
C687
--
C901
--
C7
--
C902
--
C709
--
C903
--
C710
--
C904
--
C711
--
C905
--
C712
--
C906
--
C713
--
C907
--
C714
--
C910
--
C715
--
C912
--
C716
--
C913
--
C718
--
C942
--
C729
--
C943
--
C782
--
C944
--
C794
--
C945
--
C795
--
C949
--
C796
--
C951
--
C797
--
C952
--
C798
--
C959
--
C799
--
C964
--
C802
--
C967
--
C803
--
C968
--
99
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
C970
--
R1379
--
C971
--
R138
--
C974
--
R1380
--
--
R1382
--
--
R1383
--
R1384
--
R1385
--
R1388
--
R1389
--
R139
--
R1390
--
R1392
--
R1393
--
R1394
--
R1395
--
R1396
--
R1397
--
R1398
--
R1399
--
R1401
--
R1402
--
R1405
--
R1406
--
R1407
--
R1408
--
R1409
--
R1411
--
R1412
--
R1415
--
R1416
--
R1417
--
R1418
--
R1419
--
R1420
--
C990
C997
G
G
RESISTORS
R10
--
R102
--
R103
--
R104
--
R1149
--
R1158
--
R1165
--
R1166
--
R1171
--
R1172
--
R1173
--
R1177
--
R1182
--
R1183
--
R1187
--
R1198
--
R1201
--
R1206
--
R1209
--
R1221
--
R1233
--
R124
--
R1243
--
R1244
--
R1245
--
R1248
--
R1249
--
R1265
--
R1421
--
R1309
--
R1422
--
R1310
--
R1423
--
R1311
--
R1424
--
R1313
--
R1425
--
R1314
--
R1426
--
R1330
--
R1427
--
R1331
--
R1479
--
R1332
--
R1480
--
R1333
--
R1481
--
R1335
--
R1482
--
R1350
--
R1483
--
R1355
--
R1486
--
R1356
--
R1489
--
R1357
--
R1494
--
R1358
--
R1495
--
R1364
--
R1496
--
R1365
--
R15
--
R1366
--
R1505
--
R1367
--
R1506
--
R1368
--
R1507
--
R1369
--
R1508
--
R1370
--
R1509
--
100
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
R1510
--
R1632
--
R1511
--
R1635
--
R1512
--
R1636
--
R1513
--
R1638
--
R1514
--
R1639
--
R1515
--
R1642
--
R1516
--
R1660
--
R1517
--
R1661
--
R1524
--
R1662
--
R1527
--
R1663
--
R1529
--
R1666
--
R1530
--
R1667
--
R1533
--
R1668
--
R1543
--
R1671
--
R1546
--
R1672
--
R1547
--
R1676
--
R1548
--
R1677
--
R1549
--
R1678
--
R1550
--
R1679
--
R1551
--
R1684
--
R1552
--
R1685
--
R1562
--
R1686
--
R1563
--
R1687
--
R1567
--
R1691
--
R1568
--
R1693
--
R1569
--
R1696
--
R1570
--
R1699
--
R1571
--
R1701
--
R1572
--
R1702
--
R1580
--
R1704
--
R1582
--
R1710
--
R1587
--
R1715
--
R1588
--
R1716
--
R1589
--
R1718
--
R1591
--
R1720
--
R1592
--
R1721
--
R1593
--
R1725
--
R1596
--
R1727
--
R1597
--
R1736
--
R1598
--
R1738
--
R1601
--
R1741
--
R1602
--
R1748
--
R1603
--
R1750
--
R1604
--
R1761
--
R1605
--
R1768
--
R1606
--
R1769
--
R1607
--
R1770
--
R1609
--
R1833
--
R1610
--
R1835
--
R1613
--
R1836
--
R1614
--
R1838
--
R1615
--
R1840
--
R1617
--
R1854
--
R1618
--
R1855
--
R1619
--
R1857
--
R1620
--
R1858
--
R1621
--
R1859
--
101
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
R1862
--
R1929
--
R1863
--
R1932
--
R1864
--
R1933
--
R1865
--
R1934
--
R1867
--
R1936
--
R1868
--
R1937
--
R1869
--
R1939
--
R1870
--
R1940
--
R1871
--
R1941
--
R1872
--
R1942
--
R1873
--
R1949
--
R1874
--
R1950
--
R1875
--
R1951
--
R1876
--
R1952
--
R1877
--
R1953
--
R1878
--
R1954
--
R1879
--
R1955
--
R1880
--
R1956
--
R1881
--
R1957
--
R1882
--
R1958
--
R1883
--
R1959
--
R1884
--
R1885
--
R1960
--
R1886
--
R1961
--
R1887
--
R1962
--
R1888
--
R209
--
R1889
--
R221
--
R1890
--
R222
--
R1895
--
R223
--
R1896
--
R231
--
R1897
--
R252
--
R1898
--
R344
--
R1899
--
R384
--
R1900
--
R473
--
R1901
--
R474
--
R1902
--
R483
--
R1903
--
R5
--
R1904
--
R594
--
R1907
--
R6
--
R1908
--
R620
--
R1909
--
R7
--
R1910
--
R735
--
R1911
--
R793
--
R1912
--
R8
--
R1913
--
R809
--
R1914
--
R844
--
R1915
--
R845
--
R1916
--
R884
--
R1918
--
R9
--
R1919
--
R1920
--
CN1
--
R1921
--
CN128
--
R1924
--
CN132
--
R1925
--
CN141
--
R1926
--
CN703
--
R1927
--
CN707
--
R1928
--
CN708
--
MISCELLANEOUS PARTS
102
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
CN709
--
Q813
--
CN710
--
Q814
--
--
Q827
--
--
Q827
--
--
JK10
JK2
G
G
JK4
--
Q828
JK6
--
Q831
--
PL1
35028044 GROUND_TERMINAL_MAIN_BOARD_4.2mm
--
Q833
--
PL2
35028044 GROUND_TERMINAL_MAIN_BOARD_4.2mm
--
Q834
--
PL3
35028044 GROUND_TERMINAL_MAIN_BOARD_4.2mm
--
Q837
--
PL4
35028044 GROUND_TERMINAL_MAIN_BOARD_4.2mm
--
Q841
--
S101
--
Q844
--
S102
--
Q845
--
S103
--
Q846
--
S22
--
Q857
--
S23
--
Q858
--
S25
--
Q860
--
S39
--
Q861
--
S42
--
S49
--
S5
--
D800
--
S7
--
D802
--
S76
--
D806
--
S83
--
D807
--
S85
--
D811
--
D819
--
S86
--
D823
--
S9
--
D826
--
S92
--
D842
--
S93
--
D844
--
SC1
--
D847
--
Z101
--
D851
--
Z102
--
D854
--
D857
--
D861
--
D862
--
D867
--
DIODES
17PW82
POWER SUPPLY
INTEGRATED CIRCUITS
IC800
--
--
D876
--
--
IC801
--
D878
IC802
--
D880
--
IC803
--
D882
--
IC806
--
D883
--
IC809
--
D885
--
IC811
--
D886
--
IC824
--
D887
--
IC830
--
D888
--
D894
--
IC831
--
D898
--
D900
--
TRANSISTORS
Q802
--
Q803
--
L800
--
Q804
--
L804
--
Q805
--
L811
--
Q806
--
L816
--
Q807
--
L830
--
Q810
--
L832
--
Q811
--
L833
--
Q812
--
L836
--
103
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
L837
--
C873
--
L838
--
C874
--
L840
--
C878
--
L844
--
C881
--
L845
--
C883
--
L846
--
C892
--
FR801
--
C893
--
FR802
--
C898
--
FR804
--
C901
--
FR805
--
C904
--
C913
--
C914
--
C915
--
CAPACITORS
C1023
--
C1024
--
C1025
--
C1027
--
C1029
C1030
--
C1032
--
C1033
--
C1034
--
C1035
--
C1036
--
C1037
--
C800
--
C801
--
C802
--
C803
--
C804
--
C805
--
C807
--
C810
--
C811
--
C814
--
C817
--
C818
C819
C824
C830
C916
--
C917
--
C918
--
C920
--
C925
--
C928
--
C933
--
C935
--
C938
--
C939
--
C942
--
C947
--
C948
--
C950
--
C955
--
C956
--
C966
--
C967
--
C968
--
C969
--
--
R1000
--
--
R1001
--
--
R1002
--
--
R1003
--
C833
--
R1006
--
C838
--
R1007
--
C839
--
R1010
--
C840
--
R1011
--
C841
--
R1012
--
C842
--
R1013
--
C845
--
R1014
--
C847
--
R1020
--
C849
--
R1022
--
C850
--
R1023
--
C851
--
R1024
--
C852
--
R1025
--
C855
--
R1026
--
C856
--
R1027
--
C860
--
R1030
--
C862
--
R1031
--
C863
--
R1032
--
C870
--
R1037
--
RESISTORS
104
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
R1038
--
R863
--
R1039
--
R864
--
R1040
--
R865
--
R1044
--
R866
--
R1046
--
R867
--
R1047
--
R868
--
R1048
--
R869
--
R1049
--
R870
--
R1125
--
R872
--
R1126
--
R873
--
R1127
--
R874
--
R1128
--
R875
--
R1129
--
R876
--
R1130
--
R877
--
R1133
--
R879
--
R1134
--
R881
--
R1136
--
R882
--
R1137
--
R883
--
R1138
--
R884
--
R1139
--
R887
--
R801
--
R888
--
R802
--
R889
--
R804
--
R809
--
R891
--
R810
--
R892
--
R811
--
R893
--
R812
--
R912
--
R815
--
R929
--
R817
--
R931
--
R818
--
R932
--
R819
--
R933
--
R820
--
R940
--
R822
--
R946
--
R823
--
R947
--
R824
--
R948
--
R826
--
R949
--
R828
--
R960
--
R829
--
R962
--
R831
--
R964
--
R832
--
R965
--
R833
--
R966
--
R834
--
R970
--
R836
--
R971
--
R837
--
R972
--
R838
--
R973
--
R839
--
R976
--
R841
--
R977
--
R846
--
R980
--
R852
--
R981
--
R855
--
R982
--
R856
--
R996
--
R857
--
R997
--
R858
--
R998
--
R859
--
R999
--
R860
--
R861
--
J109
--
R862
--
J110
--
MISCELLANEOUS PARTS
105
LC-32SH130E
LC-32SH130K
LC-32SH340E
REF No. PARTS
DESCRIPTION
PRICE
CODE
DESCRIPTION
PRICE
CODE
J111
--
J107
--
J112
--
J108
--
J113
--
F800
--
J114
--
F801
--
J115
--
PL800
--
J116
--
PL802
--
J117
--
PL804
--
J118
--
PL809
--
J119
--
PL813
--
J121
--
PL814
--
J122
--
PL815
--
J123
--
PL816
--
J124
--
TH1
--
J125
--
TH2
--
J126
--
TR803
--
J127
--
TR806
--
J129
--
TR810
--
J130
--
--
J131
--
--
J132
--
--
J133
--
--
J134
--
--
J135
--
--
J136
--
--
--
J137
--
--
J139
--
--
J140
--
--
J141
--
J145
--
J147
--
J148
--
J149
--
J150
--
J151
--
J152
--
J153
--
J155
--
J156
--
J158
--
J159
--
J160
--
J161
--
J162
--
J164
--
J167
--
J168
--
J169
--
J170
--
J171
--
J172
--
J173
--
J174
--
J100
--
J101
--
J102
--
J105
--
J106
--
!
!
106
LC-32SH130E
LC-32SH130K
LC-32SH340E
DESCRIPTION
PRICE
CODE
---------------
PRICE
CODE
DESCRIPTION
-------
PRICE
CODE
DESCRIPTION
107
-----
LC-32SH130E
LC-32SH130K
LC-32SH340E
125mm
100mm
80mm
63mm
COPYRIGHT
2011 BY SHARP CORPORATION
50mm
ALL RIGHTS RESERVED
No part of this publication may be reproduced,
stored in a retrieval system, or transmitted in any
form
or by any means, electronic, mechanical,
40mm
photocopying, recording, or otherwise, without
prior written permission of the publisher.
31.5mm
25mm
108