Professional Documents
Culture Documents
GM 008 02
GM 008 02
GM 008 02
Ordering Information
Use the following information when specifying a gearmotor or gear reducer from SEW. Mounting positions are shown for footed reducers. However, mounting positions are the same for flanged reducers that have the same orientation.
Unless otherwise specified, you will receive the Conduit Box @ 0 and the Cable Entry @ X
Mounting Position
R
Helical
F
Parallel Shaft
Date: Replaces:
3-2010 GM-008-01
GM-008-02
Page 1 of 4
Technical Note
Mounting Position Conduit Box & Cable Entry
(0, 90, 180, 270) (X, 1, 2, 3)
K/S/W
Right Angle
Side B Side A
Symmetrical TorqLOC Units (KT, ST)
Enter A or B
Enter A
Non-Symmetrical TorqLOC or Shrink Disc Units (KT, KH, ST, SH)
Enter B
Date: Replaces:
3-2010 GM-008-01
GM-008-02
Page 2 of 4
Technical Note
Torque Arm Position & Degrees
If you do not specify otherwise, SEW assembles the torque arm degree as shown in red.
Side A
K-series Helical-Bevel
Side B
S-series Helical-Worm
90
Side A
45 0 315 270
Side B
270
303 213
303 213
Date: Replaces:
3-2010 GM-008-01
GM-008-02
Page 3 of 4
Technical Note
Examples
For each example below, the correct ordering information is shown.
R67DT90L4 M3 270 2
Cable entry
Model Mounting Position Conduit Box Cable Entry Flange Side Shaft Side Hand Release
Hand Release
Note: This unit contains brake (BMG4) and hand release (HR), which is shown in the nomenclature.
Cable Entry
Eyebolt
Model Mounting Position Conduit Box Cable Entry Shaft Side Torque Arm Torque Arm Angle Hand Release
Date: Replaces:
3-2010 GM-008-01
GM-008-02
Page 4 of 4