Professional Documents
Culture Documents
Tutorial SW2013 3D Sketching 6
Tutorial SW2013 3D Sketching 6
Tutorial SW2013 3D Sketching 6
Page 1 of 1
4. Click the temporary axis on the face of the frame where you sketched the circle. The pointer changes to when you move it over the axis.
In the graphics area, a preview of the pattern appears, and an arrow indicating the direction of the pattern appears on the frame at the right end of the axis. In the Property Manager, Axis <1> appears in Pattern Direction. 5. Under Direction 1: a. Check the preview of the extrusions to make sure they are patterned towards the outer edge, as shown below. If necessary, click Reverse Direction b. Set Spacing to 22. to 6. to change the pattern direction.
6. Click
NEXT TOPIC
Mirroring All
mk:@MSITStore:C:\Program%20Files\SolidWorks%20Corp\SolidWorks\lang\english\ot... 11/21/2013