This circuit uses an IC555 monostable multivibrator chip to generate a square wave output signal with an on time and off time of 0.5 microseconds each and a 2 microsecond delay between transitions. The IC555 chip is triggered by a 10k resistor and 0.01 microfarad capacitors are used to set the on and off times, generating the output waveform shown.
This circuit uses an IC555 monostable multivibrator chip to generate a square wave output signal with an on time and off time of 0.5 microseconds each and a 2 microsecond delay between transitions. The IC555 chip is triggered by a 10k resistor and 0.01 microfarad capacitors are used to set the on and off times, generating the output waveform shown.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd
This circuit uses an IC555 monostable multivibrator chip to generate a square wave output signal with an on time and off time of 0.5 microseconds each and a 2 microsecond delay between transitions. The IC555 chip is triggered by a 10k resistor and 0.01 microfarad capacitors are used to set the on and off times, generating the output waveform shown.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd