Professional Documents
Culture Documents
Replace Adjusting Rod and Anchor Pin Assembly. Hammer, Brass Wrench, Socket, Ifg-In
Replace Adjusting Rod and Anchor Pin Assembly. Hammer, Brass Wrench, Socket, Ifg-In
Drive idler post into its brackets, and fasten with inner nut and cotter pin (fig. 50). (2) ASSEMBLE SHACKLE AND IDLER SHAFT TO IDLER POST. Wrench, socket, ^f-in. Wrench, socket, 1 Vs-in. Wrench, socket, l-t^-in. Drive idler shaft into shackle and fasten with nut and cotter pin. Then slip shackle onto idler post and lock with washer, nut, and cotter pin (fig. 51).
(3) REPLACE ADJUSTING ROD AND ANCHOR PIN ASSEMBLY. Hammer, brass Wrench, socket, Ifg-in. Drive anchor pin into adjusting rod end, and draw it up tight with stop nut. Slip anchor pin into tapered hole at bottom of shackle, and apply nut loosely. Thread inner bronze nut well onto adjusting rod, slide outer end of rod through bracket hole, and thread outer bronze nut onto rod (fig. 23). Tighten anchor pin nut.
Tool, bearing driving (fig. 52) or brass drift Drive inner and outer bearings into idler. If bearing driving tool is not available, use brass drift. NOTE: Do not drive inner bearing seal into idler.
BOLT-A215335
7 PD 7474
TM 9-1710C 18
ORDNANCE MAINTENANCE-CHASSIS AND BODY FOR HALF-TRACK VEHICLES
C PIN, COTTER - BFAX2CF DSHACKLE-C86020 AOILER-A215332 B_ JNUT-A215329 {WASHER -A215322 ESHAFT-C86019 F-ROD - B185117 RA PD 3529B
(5) ASSEMBLE IDLER TO SHAFT. Block, wooden Wrench, spanner, bearing nut, special Hammer, sledge Screwdriver Push inner bearing seal onto raised shoulder of shaft. Start idler onto shaft, and drive it the remainder of the distance. Replace bearing lock washer and nut; bend washer prongs to lock assembly in place. (6) REPLACE HUB COVER. Wrench, socket, -fa-in* Set hub cover on studs and draw up tight with stud nuts. d. Top (supporting) Roller (fig. 21). Tool, bearing driving Hammer Tool, seal driving Hammer, soft metal Tool, seal driving Hammer Tool, bearing driving Inspect spacer; then drive bearings and seals into roller hubs.
72
TM 9-1710C 18
BOGIE SUSPENSION AND TRACK
I
Q
0)
0>
I u
CO
'5
0)
M 0
2 .
73