Professional Documents
Culture Documents
Manual Sixpack Captain and First Officer
Manual Sixpack Captain and First Officer
Congratulations on your purchase of the FLYENGRAVITY Sixpack recall annunciator. Please read carefully the installation instructions prior to connecting to your interface board.
The MSP 250 and MSP 260 come with a 1.5 meter cable. Pay attention to properly connect the main connector to the SIXPACK module. The ends of the ribbon cable have pre fabricated sockets for easy connecting to your interface board. Figure 1.1 shows the wiring diagram
Electronic parts are sensitive devices, always make sure what you do when connecting and use the proper tools. In case of doubt, please contact our support department at support@flyengravity.com The sixpack is designed to be used with the CP flight MIP board. Please note that no resistors have been added to the main board. In case you use a different interface board, check if a resistor is installed on your interface board. Never use a direct power source to power up the leds, This will result in permanent damage of your sixpack module.
CAPTAIN
FLT CONT ELEC APU IRS FUEL OVHT/DET
F/O
ANTI-ICE HYD DOORS ENG OVERHEAD AIR COND
MSP250
COMMON CATHODE FUEL IRS FLT CONT OVHT/DET APU ELEC
MSP260
COMMON CATHODE DOORS HYD ANTI ICE AIR COND OVERHEAD ENG
Use the template below to cut out the rectangular for inserting the sixpack. The two 16 mm holes are reference cutouts for the master- and fire switch. Prior to mounting the sixpack, remove the bracket from the back. After mounting, place the bracket again to fixate the sixpack.
GROUND GROUND RECALL SWITCH RECALL SWITCH RECALL SWITCH RECALL SWITCH
16 mm
16 mm
54x29 mm
54x29 mm
16 mm
16 mm
Engravity BV 2013