Professional Documents
Culture Documents
International Development Corp.: Instructions
International Development Corp.: Instructions
INSTRUCTIONS
A
FOR FIRST TIME USE: Remove pull tab (F) in between the battery and its connector. SOLAR LIGHT NEEDS TO CHARGE IN FULL SUNLIGHT FOR 8 - 12 HOURS TO ALLOW THE RECHARGEABLE BATTERY TO REACH MAXIMUM CAPACITY.
TROUBLESHOOTING
If light doesn't turn on, remove battery, wipe both ends with a clean dry cloth and reinstall battery. Check the battery to ensure that it is making secure contact with the terminals. If this doesn't work, replace with a new battery.
B
ASSEMBLY
Slide (Part A) into (Part B). Carefully insert the stake (Part C) into the ground where desired. NOTE: If the ground is hard and packed, moisten the ground with water before inserting the stake to avoid breakage. Use a rubber mallet (not included), if necessary, to gently tap stake into ground. Firmly slide assembled (Parts A & B) on top of (Part C) until it is flush. NOTE: Some parts may come pre-assembled.
SHADE
F PULL TAB
ON/OFF SWITCH
SCREW
BATTERY
WARNING: Do not dispose of Ni-Cd batteries in the regular trash, municipal waste stream or by fire as batteries may leak or explode. Do not open, short circuit, or mutilate batteries as injury may occur. Preserve our environment by recycling Ni-Cd batteries or disposing of them in accordance with Local, State, and Federal regulations. Do not mix old and new batteries. Do not mix alkaline, standard (Carbon-Zinc), or rechargeable (Nickel Cadmium) batteries.
Item # 22321x-xx
02/23/11 E