Professional Documents
Culture Documents
Deo 1 - 1
Deo 1 - 1
Section 11 : Exercises
This section has the exercises to complete for assignment 1 (see appendix Section 12). For all exercises you will have to create: -3D model, -2D drawing with all dimension and highlight all detail, work in .drw and .pdf format. For the assignment 1 you will have to create: -On-line diary (see appendix Section 12) -Report (see appendix Section 12) Exercise 1 Draw a 3D model of the mechanical component, shown in figure 11.1.
Hints: to sketch the base of the model, you can follow the instructions given in Example 0 in section2, but in this case, you will have to draw three circles rather than two as shown in figure 11.2.
N.Fois 2013 University of Sheffield MEC6013 An introduction to SolidWorks
Section 11 : Exercises
N.Fois 2013
University of Sheffield