Professional Documents
Culture Documents
Deo 3 - 1
Deo 3 - 1
The circle with diameter 22.86 mm has a depth of cut 0.25 mm.
N.Fois 2013 University of Sheffield MEC6013 An introduction to SolidWorks
Section 11 : Exercises
When you sketch a tooth, the first step is sketch a centerline, then with the "line" feature draw a isosceles trapezoid, to set the inclination of the sides, use the features Smart dimension, click two sides the inclined line and horizontal line, it will obtain the angle between two lines. Use Linear pattern/ Circular Pattern to create all gear teeth from one single tooth. To do this select the cylinder face, input 360 for the angle, set the pattern number to pattern 22, and under features to pattern, select the tooth, as shown in figure 11.8.
N.Fois 2013
University of Sheffield
Section 11 : Exercises
Feature to pattern
Hint The 2D drawing will be different from figure 11.6, necessary highlight all detail of the gear.
N.Fois 2013
University of Sheffield