Supply List Metler Silk Finish Coton Thread artcle # 105 in coordinatng color 2 pieces 16x16 coordinatng fabrics 1 1/2 yards 3/8 coordinatng ribbon Plastc ruler Large Safety Pin Very light weight tear-away stabilizer 16 x 16 (optonal for stfer basket) Step 1. Using a rotary cuter (or scissors) cut 2 pieces of fabric and 1 piece of stabilizer (optonal) 16 x 16 square. Step 2. Fold ribbon in half and cut on fold. Step 3. Place fabric pieces right sides to- gether. If you use the stabilizer, place it on top of both fabrics.
2
Step 6. Using a 1/4 inch presser foot as a guide, sttch all around the square be- ing careful to sttch the open area closed. Step 4. Using 1/4 inch seam, sew around edges, leaving about 5 inches on one side for turning. Step 7. Decide which fabric you want for the faps to show. Lay that side of the fabric face down up the table. Fold one corner in towards the opposite corner. The fold should measure 4 from the center of the fold to the point. See picture to the lef. Step 5. Clip corners as shown and turn inside out. Press, making sure you turn the open area neatly inside.
3 Step 8. Use your ruler to make sure the points are in a straight line. Pin to hold. Go around the square and measure every corner in to measure 4 and pin. Make sure each folded point is in line with the opposite point. Your project should look like the photo on the right when you have all the folding and pinning done. Step 9. Using your presser foot as a guide, edge sttch only on the coordinatng fabric, then top sttch 1/2 inch away from the frst sttching, again, only on the coordinatng fabric.
4 Step 10. Take one piece of ribbon, pin the safety pin to it and slide it through the casing you just made and then slide it through the next casing. Take the next piece of ribbon and run it through the next two casings. Gather up the ribbon (pull both ends) and te a bow with the ends of the ribbons. Hint: If you have a diferent way to run the ribbon through the casing, use it. The safety pin is doable but it is a bit difcult. I used a small alligator surgical clamp, or a Fast Turn tool will work also. Fill your basket with potpourri or your favorite treat. It will even be useful for some fresh baked cookies. Afer all, its completely washable.