This document summarizes the material safety data sheet for Best-Vue Lens Cleaning Tissue. The tissue is saturated with a colorless solution containing less than 10% isopropanol. In the event of a spill, all ignition sources should be eliminated and any spilled material absorbed and placed in a non-leaking container for disposal. Prolonged skin contact may cause dryness, irritation, and defatting. Inhalation of vapors can cause mild irritation of eyes, nose, and throat.
This document summarizes the material safety data sheet for Best-Vue Lens Cleaning Tissue. The tissue is saturated with a colorless solution containing less than 10% isopropanol. In the event of a spill, all ignition sources should be eliminated and any spilled material absorbed and placed in a non-leaking container for disposal. Prolonged skin contact may cause dryness, irritation, and defatting. Inhalation of vapors can cause mild irritation of eyes, nose, and throat.
This document summarizes the material safety data sheet for Best-Vue Lens Cleaning Tissue. The tissue is saturated with a colorless solution containing less than 10% isopropanol. In the event of a spill, all ignition sources should be eliminated and any spilled material absorbed and placed in a non-leaking container for disposal. Prolonged skin contact may cause dryness, irritation, and defatting. Inhalation of vapors can cause mild irritation of eyes, nose, and throat.
Section I Manufacturer: Fendall Company Emergency Telephone: 847-577-7400 Address: 5 East College Drive Information Telephone: 800-543-4842 Arlington Heights, IL 60004 Date Prepared: 02/23/98 Section II - Hazardous Ingredients/Identity Information Hazardous Components OSHA ACGIH Other limits % PEL TLV recommended (optional) (Specific Chemical Identity; Common Name(s)) ISOPROPANOL CAS #0067-63-0 400 400 N/A <10 PPM PPM GLYCERINE CAS #56-81-5 <4 DETERGENT CAS NONE NONE <10 PROPRIETARY >Section III - Physical/Chemical Characteristics Boiling Point: ≈ 180- Specific Gravity (H2O=1): 0.99 190° F (82-88° C) Vapor Pressure (mm Melting Point: N/A Hg.): N/A Vapor Density (Air = 1): Evaporation Rate (Butyl Acetate = 1): N/A N/A Solubility in Water: INFINITE Appearance and Odor: TISSUE SATURATED WITH COLORLESS SOLUTION, ODOR OF ALCOHOL. >Section IV - Fire and Explosion Hazard Data Flash Point (Method Used): Flammable Limits: N/A LEL: UEL: N/A 105° F (40° C) N/A Extinguishing Media: WATER FOG, DRY CHEMICAL, C02, "ALCOHOL" FOAM Special Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS (SCBA) AND PROTECTIVE CLOTHING. WATER MAY BE INEFFECTIVE FOR FIRE FIGHTING. USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL. Unusual Fire and Explosion Hazards: N/A >Section V - Reactivity Data Stability Unstable: NO Conditions to Avoid: AVOID HEAT, SPARKS, Unstable: NO OPEN FLAMES AND CONTACT WITH STRONG Stable: YES OXIDIZING AGENTS.
Incompatibility (Materials to Avoid): DO NOT MIX WITH ANY CHEMICALS OR
CLEANING AGENTS. AVOID CONTACT WITH CAUSTICS, AMMONIA AND ACIDS. Hazardous Decomposition or Byproducts: CARBON MONOXIDE (CO) Hazardous May Occur: Conditions to Avoid: AVOID HEAT, SPARKS, NO OPEN FLAMES AND CONTACT WITH STRONG Polymerization OXIDIZING AGENTS. Will Not Occur: YES >Section VI - Health Hazard Data Route(s) of Entry: Inhalation? YES Skin? NO Ingestion? YES NOT FOR TOPICAL USE Health Hazards (Acute and Chronic): EFFECTS OF ACUTE OVEREXPOSURE: EYES: LIQUID AND VAPOR MAY BE IRRITATING TO THE EYES. SKIN: PROLONGED OR REPEATED CONTACT MAY CAUSE DRYNESS, IRRITATION AND DEFATTING OF THE SKIN. INHALATION: CAN CAUSE MILD IRRITATION OF EYES NOSE AND THROAT. CONCENTRATIONS ABOVE TLV MAY RESULT IN HEADACHE AND DROWSINESS. INGESTION: INGESTION OF A LARGE QUANTITY MAY CAUSE DROWSINESS AND LOSS OF CONSCIOUSNESS. STOMACH CRAMPS, PAIN NAUSEA AND DIARRHEA MAY ALSO RESULT. Carcinogenicity: NTP? NO IARC Monographs? NO OSHA Regulated? NO Signs and Symptoms of Exposure: EYE, SKIN OR GASTRIC IRRITATION. Medical Conditions Generally Aggravated by Exposure: NONE KNOWN Emergency First Aid Procedures: EYES: FLUSH WITH CLEAR WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. IF IRRITATION PERSISTS SEE MEDICAL AID. SKIN: WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES. DO NOT REUSE UNTIL CLEANED. IF IRRITATION PERSISTS SEE MEDICAL AID. INHALATION: REMOVE TO FRESH AIR IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION AND GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUIDS INTO LUNGS. GET MEDICAL ATTENTION AT ONCE. >Section VII - Precautions for Safe Handling and Use Steps to Be Taken in Case Material is Released or Spilled: ELIMINATE ALL IGNITION SOURCES. FOR SMALL SPILLS TAKE UP WITH AN ABSORBENT MATERIAL AND PLACE IN A NON-LEAKING CONTAINER SUITABLE FOR DISPOSAL Waste Disposal Method: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. Precautions to Be Taken in Handling and Storing: KEEP LIQUID AND VAPOR AWAY FROM HEAT, SPARKS, AND FLAMES. KEEP CONTAINER IN COOL, DRY AREA. KEEP CONTAINER TIGHTLY CLOSED. KEEP OUT OF REACH OF CHILDREN. DO NOT REUSE EMPTY CONTAINERS. DISPOSE OF IN SUITABLE AREA. MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER BEFORE EATING, SMOKING, DRINKING OR USING TOILET FACILITIES. Other Precautions: N/A >Section VIII - Control Measures Ventilation Local Exhaust: SUFFICIENT TO Special: N/A PROVIDE SAFE WORK AREA Mechanical: ADEQUATE VENTILATION Other: N/A Protective Gloves: NONE Eye Protection: NONE REQUIRED FOR REQUIRED FOR NORMAL NORMAL PRODUCT USE PRODUCT USE Other Protective Clothing: NONE REQUIRED FOR NORMAL PRODUCT USE Work Hygienic Practices: ALWAYS FOLLOW SAFE WORK PRACTICES
Raymond Murphy-English Grammar in Use With Answers and CD ROM - A Self-Study Reference and Practice Book For Intermediate Students of English-Cambridge University Press (2004)