Professional Documents
Culture Documents
Acabamentos MSS SP-6
Acabamentos MSS SP-6
STOCK FINISH
The most widely used of any gasket finish, because, practically, is suitable for all ordinary
service conditions. This is contonuous spiral froove. Flanges sizes 12" and smaller, are
produced with a 1/16" round-nosed tool at a feed of 1/32" per revolution. For sizes 14" and
larger, the finish is made with 1/8" round-nosed tool at a feed of 3/64" per revolution.
This finish is produced by using a 90included-angle [V] tool, making a spiral groove 1/64" deep of
1/32".
CONCENTRIC SERRATED
This finish a produced by using a 90 included-angle [V] tool, making concentric groove 1/64" deep and
1/32 apart.
SMOOTH FINISH
1.
2.
The gasket contact surface does not exceed 125 microinch (3.2 ) roughness.
3.
RING JOINT
The inside wall surface of gasket groove does not exceed 63 microinch (1.6 ) roughness.
4.
BLIND
Bland flanges need not be faced in the center if, when this center part is raised, its diameter is at
least 1 in. smaller than the inside diameter of fittings of the corresponding pressure class.
When the center part is depressed, its diameter is not greater than the the inside diameter of the
corresponding pressure class fitting, Maching of the depressed center is not required.