PSX Pin 5 - Composite Sync - Wired to CSync on VGA (Pin 13)
PSX Pin 8 - Common Ground - Wired to Red Ground on VGA (Pin 6) [nb. i intend to join all of the VGA grounds together later on] PSX Pin 9 - PSX Blue - Wired to Blue on VGA (Pin 3) PSX Pin 10 - +5V - Wired to DCC on VGA (Pin 9) - Needs to be connected, else the LCD doesn't power up. PSX Pin 11 - PSX Red - Wired to Red on VGA (Pin 1) PSX Pin 12 - PSX Green - Wired to Green on VGA (Pin 2) This works if your video card can output CSync on pin 13 (13 is also HSync if it outputs seperate HSync / VSync). Settings for Powerstrip (http://nakoruru.dnsalias.com/serio/...PSOne%20LCD.png): Pixel Clock: 15.163mhz (or around there) Composite Sync: checked Interlaced: checked. Horizontal sync: Positive Vertical sync: Positive Horizontal: Scan rate: 16.2 khz (or thereabouts) Active: 720 pixels, 47.484 microseconds. Front porch: 42 pixels, 2.770 microseconds. Sync width: 96 pixels, 6.331 microseconds. Back porch: 78 pixels, 5.144 microseconds. Total: 936 pixels, 61.729 microseconds. Vertical: Refresh rate: 25.155hz (or thereabouts) Active: 576 lines, 35.556 milliseconds. Front porch: 42 lines, 2.593 milliseconds. Sync width: 4 lines, 0.247 milliseconds. Back porch: 22 lines, 1.358 milliseconds. Total: 644 lines, 39.754 milliseconds. RICHTIG: VGA LCD 1 (red) 11 2 (green) 12 3 (blue) 9 6, 7, 8 (RGB Ground) 8 9 (DCC/optional) 10 13 (Hsync/Csync) 6 PSONE OUTPUT: Pin Name Description 1 Gmd Ground 2 Rt Right Audio 3 Gnd Ground 4 Lt Left Audio 5 Y S-Video Y 6 Sync NTSC Video/Composite Sync* 7 C S-Video C 8 V-Gnd Video Ground 9 B Blue 10 +5v +5 Volt 11 R Red 12 G Green http://www.gamesx.com/avpinouts/psxav.htm http://www.hut.fi/Misc/Electronics/circuits/vga2rgbs.html