The document provides instructions for using a W995 scanner to scan for signals in 10 steps: 1) choose the main scanner, 2) connect all measurement servers, 3) set the air interface properties, 4) lock the network mode to WCDMA, 5) set the radio access technology, 6) change the speech codec setting, 7) set the WCDMA cell selection, 8) configure the scanner properties, 9) save the logfile and start recording, and 10) begin scanning.
The document provides instructions for using a W995 scanner to scan for signals in 10 steps: 1) choose the main scanner, 2) connect all measurement servers, 3) set the air interface properties, 4) lock the network mode to WCDMA, 5) set the radio access technology, 6) change the speech codec setting, 7) set the WCDMA cell selection, 8) configure the scanner properties, 9) save the logfile and start recording, and 10) begin scanning.
The document provides instructions for using a W995 scanner to scan for signals in 10 steps: 1) choose the main scanner, 2) connect all measurement servers, 3) set the air interface properties, 4) lock the network mode to WCDMA, 5) set the radio access technology, 6) change the speech codec setting, 7) set the WCDMA cell selection, 8) configure the scanner properties, 9) save the logfile and start recording, and 10) begin scanning.
How to using W995 for signal scanning Choose the MS for scanning Click the button for connect all MS Right click MS1 Air Interface. Then choose Equipment Properties Lock the network mode to WCDMA Click Apply Radio Access Technology (RAT) Lock Setting Speech Codec Setting Change to Modified Mode Only selected the UmtsAmrWb, then click OK WCDMA Cell Selection Setting Setting WCDMA Cell Selection to Modified (type), Control Mode (Lock), UARFCN (10563) for 3 Operator, and None Selected for Scrambling codes Please Setting as this Scanner Properties Setting Saving The Logfile and Recording Click The Record button for Recording After click the Record button then Click Start Scanning Thank You Very Much