This document provides warnings and instructions for uncrating and installing woven belts produced by Ashworth Bros., Inc. Care must be taken to prevent permanent damage to the belt's mesh from unseated spirals. The belt should be kept under uniform tension across its full width to avoid waviness in the mesh surface. Any waviness that appears should be smoothed out immediately by hand to reseat spirals, checking under tension. Special care is needed to watch for and correct unseated spirals during uncrating and installation for the belt to provide the best service.
This document provides warnings and instructions for uncrating and installing woven belts produced by Ashworth Bros., Inc. Care must be taken to prevent permanent damage to the belt's mesh from unseated spirals. The belt should be kept under uniform tension across its full width to avoid waviness in the mesh surface. Any waviness that appears should be smoothed out immediately by hand to reseat spirals, checking under tension. Special care is needed to watch for and correct unseated spirals during uncrating and installation for the belt to provide the best service.
This document provides warnings and instructions for uncrating and installing woven belts produced by Ashworth Bros., Inc. Care must be taken to prevent permanent damage to the belt's mesh from unseated spirals. The belt should be kept under uniform tension across its full width to avoid waviness in the mesh surface. Any waviness that appears should be smoothed out immediately by hand to reseat spirals, checking under tension. Special care is needed to watch for and correct unseated spirals during uncrating and installation for the belt to provide the best service.
Winchester, VA PHONE: 540-662-3494 FAX: 540-662-3150 003B0199 This document contains confidential information and trade secrets of Ashworth Bros., Inc. It may not be reproduced in whole or in part, or used for the benefit of anyone other than Ashworth Bros., Inc. Page 1 of 1
UNCRATING WOVEN BELTS
WARNING--WARNINGWARNING
READ THIS BEFORE UNCRATING OR INSTALLING YOUR BELT
On wide mesh belts or belts with long spirals, extreme care must be taken during uncrating and installation, to prevent permanent damage to the mesh.
Pull on the belt with uniform tension across the full width to prevent unseating of the spirals from the crimped connectors. A section that has become unseated will create a waviness (pockets, bulges, or spirals standing up on end) in the mesh surface when tension is applied. THIS CAN CAUSE PERMANENT MESH DISTORTION IF NOT CORRECTED IMMEDIATELY. Keep the belt under tension whenever possible. Avoid undue handling while joining sections, uncrating, etc. If waviness appears, remove all tension in that local area and smooth out (reseat) the spirals by hand. Recheck under tension. Repeat the process as necessary. Pockets not removed may cause accelerated wear on the mesh surface in that area or mistracking of the belt.
REMEMBER TO WATCH THE BELT FOR UNSEATED SPIRALS CAREFULLY DURING UNCRATING AND INSTALLATION TO GET THE BEST SERVICE FROM YOUR NEW BELT.
If you have any problems or concerns consult Ashworths Product Engineering.