This document provides technical specifications and drawings for a PJ8 pulsejet engine, including dimensions and materials for components like the valve plate, reed valve, intake cone, fuel injector nozzle, blast ring, and intake venturi. The nominal thrust of the engine is 8lbs. The original drawings are from September 2001 and were last revised in March 2002.
This document provides technical specifications and drawings for a PJ8 pulsejet engine, including dimensions and materials for components like the valve plate, reed valve, intake cone, fuel injector nozzle, blast ring, and intake venturi. The nominal thrust of the engine is 8lbs. The original drawings are from September 2001 and were last revised in March 2002.
This document provides technical specifications and drawings for a PJ8 pulsejet engine, including dimensions and materials for components like the valve plate, reed valve, intake cone, fuel injector nozzle, blast ring, and intake venturi. The nominal thrust of the engine is 8lbs. The original drawings are from September 2001 and were last revised in March 2002.
This document provides technical specifications and drawings for a PJ8 pulsejet engine, including dimensions and materials for components like the valve plate, reed valve, intake cone, fuel injector nozzle, blast ring, and intake venturi. The nominal thrust of the engine is 8lbs. The original drawings are from September 2001 and were last revised in March 2002.
Nominal thrust: 8lbs Original Drawing 10-Sept-2001 Last Revised 22-March-2002 10 mm 8 mm 68 mm R23.5 mm Valve plate, 6061 aluminum 54 mm 8 mm 69.5 mm 67.3 mm 2 mm 10 mm Reed Valve 0.006" or 0.008" spring steel 38 mm 37.5 mm M8 thread Intake cone (injected version) 6061 aluminum Intake cone (aspirated version) 6061 aluminum M8 thread 38 mm 38 mm 10 mm 24 mm 3.5 mm 8 mm 42 mm Fuel Injector Nozzle 303 or 304 stainless 8 fuel holes 1.5mm 500 mm 100 mm 69 mm 84.3 mm 40 mm Blast Ring (injected version only) 0.5mm stainless steel 68 mm 54 mm 15.2 mm 50 mm 8 mm 14mm x 1.5mm spacer dual valve reatainer plates spun from 0.5mm 304 stainless steel 68 mm 10.9 mm 30 mm 60.4 mm 45.8 mm 69.5 mm 11.9 mm Intake venturi spun from 1.2mm 1020 aluminum all dimensions are "inside" measurements Engine tube cut, rolled, welded from 0.5mm 304 stainless. All dimensions are "outside" measurements.