The document provides instructions for building an F-15 Eagle model airplane out of Depron foam, including recommended servo placement 10 inches aft of the intake on both sides of the plane and suggested control surface linkage ideas. It notes that rudders are required for high alpha turns and encourages donations to support further plane designs by the creator.
The document provides instructions for building an F-15 Eagle model airplane out of Depron foam, including recommended servo placement 10 inches aft of the intake on both sides of the plane and suggested control surface linkage ideas. It notes that rudders are required for high alpha turns and encourages donations to support further plane designs by the creator.
The document provides instructions for building an F-15 Eagle model airplane out of Depron foam, including recommended servo placement 10 inches aft of the intake on both sides of the plane and suggested control surface linkage ideas. It notes that rudders are required for high alpha turns and encourages donations to support further plane designs by the creator.
Depron Dave's F-15 Eagle F Suggested CG point Thanks for downloading this plane It's all 3mm depron with a carbon spar for the wing Refer to the pics posted on RCGroups.com For linkage ideas, NOTE: this plane will not perform "high alpha" turns without rudders! If you like the plane maybe consider donating to my depron PAYPAL fund at deprondave@yahoo.com by doing this I'll design more and more and more and more...................................someone stop me...!!! .5MM X 3MM full wingspan CARBON SPAR .5MM X 3MM full wingspan CARBON SPAR .5MM X 3MM full wingspan CARBON SPAR .5MM X 3MM full wingspan CARBON SPAR .5MM X 3MM full wingspan CARBON SPAR