The document provides instructions for setting the nominal speed and adjusting the trip points of an engine controller. It describes connecting the controller to set the nominal speed, and using preset potentiometers to adjust the trip points between 90-140% of nominal speed. It also mentions using PC software to configure settings and view wiring diagrams and dimensions.
The document provides instructions for setting the nominal speed and adjusting the trip points of an engine controller. It describes connecting the controller to set the nominal speed, and using preset potentiometers to adjust the trip points between 90-140% of nominal speed. It also mentions using PC software to configure settings and view wiring diagrams and dimensions.
The document provides instructions for setting the nominal speed and adjusting the trip points of an engine controller. It describes connecting the controller to set the nominal speed, and using preset potentiometers to adjust the trip points between 90-140% of nominal speed. It also mentions using PC software to configure settings and view wiring diagrams and dimensions.
With the DSE402 MKII connected, run the engine at nominal speed. Connect the Set Nominal Speed input to battery negative to set the nominal speed.
ADJUSTMENT OF TRIP POINTS Turn the pre-set potentiometers to set the trip point. The factory setting for the Trip is 90% to 140% . The range is adjusted from 0% to 400% of nominal engine speed via the DSE Configuration Suite Lite PC Software. Turn the pre-set potentionmeters clockwise to increase the trip point, turn it anti-clockwise to decrease the trip point. The Engine Overspeed LED will illuminate when the trip has been achieved.
PC CONFIGURATION PC configuration is achieved using the DSE813 interface and DSE Configuration Suite Lite PC Software. For further information on PC Configuration, please refer to DSE publication: 057-138 DSE402 MkII Software Manual
DEEP SEA ELECTRONI CS DSE402 MKI I I NST ALL AT I ON I NSTRUCTI ON
053-087 ISSUE 1
TYPICAL WIRING DIAGRAM DIMENSIONS 224 mm x 314 mm x 140 mm (8.7 x 12.2 x 5.5) PANEL CUTOUT 80 mm x 130 mm (3.1 x 5.1) MOUNTING Screw Size: M4 Torque Rating: 0.60 Nm
Larger versions of the diagrams can be found in the products operator manual. DSE publication: 057-137 DSE402 MkII Operator Manual