This document provides product information for wide mouth beam clamps manufactured by PHD Manufacturing, Inc. It lists available sizes of the clamps in a table with their maximum recommended pipe/rod sizes and loads. It describes the function of the clamps as designed to attach hanger rods to beam flanges up to 1-1/4 inches thick. It notes approval listings and material specifications. Ordering instructions are given to specify rod size, finish, and figure number.
This document provides product information for wide mouth beam clamps manufactured by PHD Manufacturing, Inc. It lists available sizes of the clamps in a table with their maximum recommended pipe/rod sizes and loads. It describes the function of the clamps as designed to attach hanger rods to beam flanges up to 1-1/4 inches thick. It notes approval listings and material specifications. Ordering instructions are given to specify rod size, finish, and figure number.
This document provides product information for wide mouth beam clamps manufactured by PHD Manufacturing, Inc. It lists available sizes of the clamps in a table with their maximum recommended pipe/rod sizes and loads. It describes the function of the clamps as designed to attach hanger rods to beam flanges up to 1-1/4 inches thick. It notes approval listings and material specifications. Ordering instructions are given to specify rod size, finish, and figure number.
3 /4 1 3 /8 2 3 /8 2 3 /8 3 /4 6 900 .87 Max. Pipe Size Rod Size A B C E D FUNCTION: Designed for attaching hanger rod to the top fange of a beam or bar joist, where the fange thickness does not exceed 1 1 /4 inches. The open U design permits rod adjustment. APPROVALS: Underwriters Laboratories Listed in the U.S. (UL), Canada (CUL), and Factory Mutual Approved for rod sizes 3 /8" and 1 /2" only. Complies with Federal Specifcations A-A-1192A (Type 19) and Manufacturers Standardization Society ANSI/SP-69 and SP-58 (Type 19). (Approvals are only for Fig. 360 with locknut). MATERIAL: Malleable iron with hardened steel cup point set screw FINISH: Plain or electro-galvanized ORDERING: Specify rod size, fnish and fgure number. 1 1 /4" Max. Rec. Load/lbs. Wt. Each (in lbs.) Note: See MSS ANSI/SP-69 and SP-58 specifcations for proper set screw torque values.