The document provides instructions for cutting and installing fixed shelves in a unit:
1) Cut vertical supports and shelves to size using a circular saw with a melamine blade and smooth edges with a planer. Apply edge tape for a finished appearance.
2) Drill screws into predrilled holes in verticals and lower shelves into place, then lock shelves down with screws.
3) Mark and drill holes for shelf pins and brackets by using a pegboard as a guide. Plumb and level the unit then fasten shelves to the wall.
The document provides instructions for cutting and installing fixed shelves in a unit:
1) Cut vertical supports and shelves to size using a circular saw with a melamine blade and smooth edges with a planer. Apply edge tape for a finished appearance.
2) Drill screws into predrilled holes in verticals and lower shelves into place, then lock shelves down with screws.
3) Mark and drill holes for shelf pins and brackets by using a pegboard as a guide. Plumb and level the unit then fasten shelves to the wall.
The document provides instructions for cutting and installing fixed shelves in a unit:
1) Cut vertical supports and shelves to size using a circular saw with a melamine blade and smooth edges with a planer. Apply edge tape for a finished appearance.
2) Drill screws into predrilled holes in verticals and lower shelves into place, then lock shelves down with screws.
3) Mark and drill holes for shelf pins and brackets by using a pegboard as a guide. Plumb and level the unit then fasten shelves to the wall.
Mark cutlines for verticals and allow for (at least) 1jg"
waste. Cut verticals with a circular saw with a melamine blade.
Smooth edges down to actual cutlines with a planer. cut the shelves according to your custom design, using a circular saw with a melamine blade. Apply heat-activated veneer tape to all exposed edges for a finished appearance. F. INSTALLING FIXED SHELVES 1. Drill KD screws into the pre drilled holes on verticals. Lower the top shelf into place. 2. Lock down shelf KDs over KD screws using a screwdriver. 3. Repeat this process for each fixed shelf. Measure 3fs" on center to first shelf-pin hole down from the top cut edge of vertical. Align pegboard holes to first two marks and about 1 W' from side edges of vertical. Drill two rows of parallel holes in each vertical, using the pegboard as a guide. D Mark KD locations on top fixed shelf, and then (inset) drill holes for KDs. Repeat for all fixed shelves. F Lock down fixed shelves with a Phillips screwdriver. Position the screwdriver at 25and twist clockwise until top shelf and vertical are pulled together. Note: For fixed shelves that align with another f7Xed shelf on the other side of the same vertical, use a KD screw and dowel or ("connector bolt"). 4. Plumb and level the entire unit; then fasten each fixed shelf to the wall with two steel L-brackets. Basics 47