6FF40, ID, 6FF28 Schlumberger Rcor-7 6-11 Charts Rcor-5, Rcor-6 and Rcor-7 correct the induction logs (6FF40, ID, 6FF28 and IM) for bed thickness. A skin-effect correction is included in these charts. To use, select the chart appropriate for the tool type and for the adjacent bed resistivity (RS). For Charts Rcor-5 and Rcor-6, enter the bed thickness and proceed upward to the proper Ra curve. Read the corrected resistivity value (Rt) in ordinate. For Chart Rcor-7, enter the chart with the RID/RS ratio (apparent ID reading/adjacent bed resistivity) and go upward to the bed thickness. Read the correction factor (RIDcor/RID) in ordinate. Example: RID = 4.2 ohm-m RIM = 6.0 ohm-m RS = 2.0 ohm-m Bed thickness = 3 m giving, from the RS = 2 ohm-m charts, RIDcor = 4.5 ohm-m RIMcor = 6.2 ohm-m For the small-diameter 6FF28, multiply the bed thickness by 1.43 before entering these correction charts. For example, in a 7-ft bed, the bed thickness used in correcting the 6FF28 reading is 10 ft (7 1.43 = 10). 1.0 0.9 0.8 0.7 0.6 0 0.2 0.4 0.6 0.8 1.0 4 1 .2 3 .5 1 .1 3 0 . 9 2 . 5 0 . 8 2 0 . 6 0.05 0.1 0.3 0.4 0.5 0.6 0.8 0.2 R ID /R s R t /R s R IDcor /R ID B e d th ic k n e s s (ft) (m ) 6FF40 or ID R t > 1 ohm-m Computed for a shoulder-bed resistivity (SBR) setting of 1 ohm-m (refer to log heading) Schlumberger Resistivity