1) The document describes a "recovery method" to reprogram a cam module if it cannot be updated with a programmer.
2) The method involves using a decoder to power the cam, inserting the cam and programmer, and using X-Loader software to fake the cam and reprogram the firmware into block 2 instead of block 14.
3) Additional steps include verifying the firmware update, programming parameters, and ensuring the cam reads as a "new virgin cam" once complete.
1) The document describes a "recovery method" to reprogram a cam module if it cannot be updated with a programmer.
2) The method involves using a decoder to power the cam, inserting the cam and programmer, and using X-Loader software to fake the cam and reprogram the firmware into block 2 instead of block 14.
3) Additional steps include verifying the firmware update, programming parameters, and ensuring the cam reads as a "new virgin cam" once complete.
1) The document describes a "recovery method" to reprogram a cam module if it cannot be updated with a programmer.
2) The method involves using a decoder to power the cam, inserting the cam and programmer, and using X-Loader software to fake the cam and reprogram the firmware into block 2 instead of block 14.
3) Additional steps include verifying the firmware update, programming parameters, and ensuring the cam reads as a "new virgin cam" once complete.
When it is not possible to update your cam with the programmer than can you try this we call it the recovery method 1) Use a Decoder that powers the CAM also in Stand By 2) Insert the CAM into the Decoder in off (not powered) 3) Insert the serial programmer into your XCAM 4) Switch-on the decoder and go to a FTA channel 5) Verify the installed firmware (1.01 or 1.02 or 1.03T) 6) On the PC start the X-Loader Program Now its where you have to fake your CAM. All of you is aware of the fact that in Block 2 you should write the Firmware an d on Block 14 the softcam.key. In this case (and remember on in this case of anomalous CAM), you shall insert t he softcam.key in block 2 instead of block 14. 7) Press Connect 8) Go to the CAM parameters 9) Activate the loader 10) The programming starts 11) At the end of programming, do not exit from the program X-Loader !!!!! 12) With the remote, verify the CAM parameter 13) You should now read XCAM Module like a new virgin CAM!! 14) Now you can load the new firmware in the X-Loader and program it in block 2 of your CAM 15) Press connect (without doing anything in the CAM menu) and the firmware down load will start automatically. 16) At the end of download, switch off the decoder (not powered) and remove the programmer without removing the CAM from the decoder 17) Switch on the decoder on the previously selected FTA channel 18) Read CAM parameter to verify correct firmware updating ------------------ Hi there, Read this !!!. This is the mail a send to any one. Hi, Yes i am can reprogram the bootloader into the cam. But i have to open the cam ( you almost see noting) and reprogram it external. The cost of the bootloader repair is 10 Euro for one cam, and about 3.00 Euro fo r the postal. If i have to send it back with registered mail the cost are 7 Euro. And i am not responsible for lost mail. You my put 10 Euro and the cost of the postal to the cam Please don't forget your return address and by sure i am can read it !!! There you cam read .... If i have to send it back with registered mail the cost are 7 Euro. And i am not responsible for lost mail. So a hope no body blame me. You know it before you send it what can happend if you do not send it whit regis tered mail. IT CAN BE LOST ? Greetings Ron