This document provides details on insulated roof and wall systems, including eaves beam gutter support, parapet flashing, air seals, and insulation. It specifies thermal data for 0.25 and 0.35 U-value gutters and notes that component changes will affect the given values. Factory made membrane lined gutters are available with insulation to 0.25 or 0.35 W/m2K U values.
This document provides details on insulated roof and wall systems, including eaves beam gutter support, parapet flashing, air seals, and insulation. It specifies thermal data for 0.25 and 0.35 U-value gutters and notes that component changes will affect the given values. Factory made membrane lined gutters are available with insulation to 0.25 or 0.35 W/m2K U values.
This document provides details on insulated roof and wall systems, including eaves beam gutter support, parapet flashing, air seals, and insulation. It specifies thermal data for 0.25 and 0.35 U-value gutters and notes that component changes will affect the given values. Factory made membrane lined gutters are available with insulation to 0.25 or 0.35 W/m2K U values.
Parapet flashing with 150mm sealed butt straps Air seal - 6mm DIA bead of gun grade sealant Air seal - 8mm Butyl rubber sealant AWP filler with gun grade sealant Building Regulations Part L2 Thermal data 0.25 U gutter fmin =0.89 Y =0.12W/mK 0.35 U gutter fmin =0.89 Y =0.19W/mK 0.35 sole width 300mm, values for other widths available onrequest. The above valves are only applicable to the components onthis detail. Changes to the components will have an affectonthe givenvalues.
Factory made membrane lined gutter with LPC approved Insulation
to 0.25 or 0.35W/m2K U value KS1000 LP/LPCB Insulated roof Panel KS1000 MR/LPCB Vertically laid PIR board insulation with Alfasbond FR canister applied insulation to fill any gaps if required to maintain continunity of insulation 6mm Butyl rubber sealant 75mm Gun grade seal at panel joints inline with 8mm butyl Top sheet turned down on site with roof pitches below 4