The document provides an example SPICE simulation file to model mutual inductances between two inductors. It includes:
1) The syntax for defining a mutual inductance with a coupling coefficient K between inductors L1 and L2.
2) A complete SPICE file that simulates two inductively coupled coils with a coupling coefficient of 0.693 using voltage and current measurements.
3) Remarks that SPICE requires all nodes to be referenced to node 0 and cannot allow a voltage source in parallel with an inductor without a small series resistor.
The document provides an example SPICE simulation file to model mutual inductances between two inductors. It includes:
1) The syntax for defining a mutual inductance with a coupling coefficient K between inductors L1 and L2.
2) A complete SPICE file that simulates two inductively coupled coils with a coupling coefficient of 0.693 using voltage and current measurements.
3) Remarks that SPICE requires all nodes to be referenced to node 0 and cannot allow a voltage source in parallel with an inductor without a small series resistor.
The document provides an example SPICE simulation file to model mutual inductances between two inductors. It includes:
1) The syntax for defining a mutual inductance with a coupling coefficient K between inductors L1 and L2.
2) A complete SPICE file that simulates two inductively coupled coils with a coupling coefficient of 0.693 using voltage and current measurements.
3) Remarks that SPICE requires all nodes to be referenced to node 0 and cannot allow a voltage source in parallel with an inductor without a small series resistor.
Example of SPICE simulation of mutual inductances The syntax for a mutual inductance is as follows: Kname Inductor1 Inductor2 value_of_K In which K is the value of the coupling coefcient that determine the mutal inductance: M=K.sqrt(L1xL2). An example of a complete SPICE le for the circuit given below follows. (K=M/sqrt(L1xL2)=0.693) Vin 1 0 sin(0 5 159.15 0 0) Rs 1 3 100 Rl 4 0 500 L1 3 0 10M L2 4 0 2M K L1 L2 0.693 .TRAN 0.1M 10M .PRINT TRAN V(3) V(4) .PLOT TRAN V(3) V(4) .END Remarks: SPICE always needs a reference node numbered 0. One can never leave any node oating. For that reason we have connected the two coils together to node 0 (or put a large resistor between it). As there is no current owing through this section, the circuit will not change by connecting these nodes. 1. SPICE does not allow to connect a voltage source in parallel with an inductor, as it thinks that the voltage source is short circuited. You can place a small resistor (ex. 0.001 Ohm) in series with the voltage source to overcome this problem. 2. Back to Spice Guidelines Jan Van der Spiegel; jan@ee.upenn.edu Created Sept. 30, 1995; Updated Feb. 8, 2007 Example Mutual Inductors http://www.seas.upenn.edu/~jan/spice/spice.mutualInductor.html 1 de 1 30/01/13 16:03