Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

SW0538

1
U Us se er r' 's s G Gu ui id de e

1. Introduction
CD-R KING SW0538 Switch, high performance switch provides 5 Fast Ethernet ports to
segment network traffic, extend Fast Ethernet connection distance, and convert data packets
between different transmission speeds. Importantly it provides the Auto MDI/MDI-X function on
all of UTP ports whether the cable is straight or cross-over type, you can connect it to other
switch or hub easily.
CD-R KING SW0538 Switch doesnt need to install any software or cost your time to
maintain. It is the easiest, most economical solution to incrementally upgrade 10Mbps switching
to 100Mbps switching for small workgroups or SOHO network users.
CD-R KING SW0538 Switch provides 5-shielded RJ-45 ports with 10Base-T/100Base-TX
Auto-negotiation capability. All of UTP ports support full & half duplex modes which are able to
provide 200Mbps of bandwidth, the auto-negotiation function providing smooth migration from
Ethernet to Fast Ethernet.
2. Specifications
Standard IEEE802.3,IEEE802.3u,IEEE802.3X
Cable Cat,3,4,5,5e,6,7 UTP/STP
Port 5 10/100Mbps Auto-Negotiation ports
Duplex Modes All Ports(Up to 200Mbps)
Uplink All ports Auto MDI/MDIX(Auto Uplink)
Protocol CSMA/CD
Architecture Store & Forward
Filter/Forward Rate
10 BASE-TX-14800pps (packets/sec.)
100 BASE - TX- 148800ppspackets/sec.)
Mac Address 2K
LED Power 1 LED ,10/100Mbps Link LED per Port
Material Plastic
Power DC 5V/500MA
Operating Temperature 0~55
Storage Temperature -20~65
Operating Humidity 5%~95% non-condensing
Size 102mm x 75mm x 30mm

SW0538

2
3. Hardware Description
LED Function
LED COLOR STATUS DESCRIPTION
Power Red
ON Power is supplied
Off No power
Link/ACT Green
ON A valid link is established
Flash
Data packets transmitted and
Received
Off No link is established

Content
1*Power adapter
1*Switch
1*Users guide

HUB to HUB connection
CD-R KING SW0538 switch supports Auto Uplink (Auto MDI/MDIX).
Therefore, it allows to use straight-through or cross-over type to connect this switch to
workstation or hub.

You might also like