Aim: The aim of this project is to build an automatic school bell system.
Block Diagram:
Power Supply:
Description:
This project is very useful for college and office automation. This electronic project going to automatically ringing the bell at a correct time replacing manual switching including RTC. In this project we use one time keeping chip called DS1307. Power supply to all sections
Step down T/F Bridge Rectifier Filter Circuit Regulator
This chip is programmed using the concept of I2C.Normally RTC continuously updating the time & displaying on LCD. We are going to set particular time (bell ringing time) using the 4x4 keypad. When this time is equal to that of bell ringing time, the relay for the bell is switched on. After some time (specific duration of time) again switches off the relay .The Bell off time also we can set by using 4x4matrix keypad.
Hardware Requirements:
AT89S52 LCD Keypad DS1307 buzzer
Software Requirements:
Knowledge on 8051 programming Knowledge on KEIL micro vision IDE