-> Open and Run the file SPMultiPortFlashDownloadProject.exe
-> A window will open like as shown below. Select Scater file
-> Select the Scater file as shown below from the folder Firmware. Scater file is present inside the folder Firmware
-> Once the Scater file is loaded, it will look like below.
-> Make sure you select Scan Preload Port and also as shown below verify all the options which is circled in Red, and click Save.
-> After clicking Save, below window will appear.
-> Select as per Red circle and click Scan
-> After clicking Yes, connect the phone (without battery) to PC using the USB cable. After few seconds, the Scan will be successful:
HINT: In this step, if the scan is not successful or if the window just stays without any progress of successful scan, then you have probably not installed the driver as guided in the very first step. Alternatively, you can also follow manual way of driver installation from your Systems Device manager. The drivers are given in the folder Generic USB Driver.
-> After successful scan, click Stop All.
-> After clicking Stop All, select only the scanned COM and click Start next to it as shown below:
-> After clicking Start, remove the USB cable from the phone, wait for 2 seconds and re-connect again. ->
-> The download will start automatically as shown below:
-> Once you see DL OK and 100% yellow bar, then you can exit the Window.
Remove the cable from the phone, insert the battery and start the phone. The camera driver is now installed and the phone is ready to use now!
Windows Operating System: Windows Operating System (OS) Installation, Basic Windows OS Operations, Disk Defragment, Disk Partitioning, Windows OS Upgrade, System Restore, and Disk Formatting