SELECTION AND LOAD RATING OF ROLLER FOR INDOOR CONVEYORS When selecting the roller, both the shaft load and the shell load must be considered. Study for the shaft load covers also the bearing load rating and the study for the shell covers the end cap load rating.
SELECTION AND LOAD RATING OF ROLLER FOR INDOOR CONVEYORS When selecting the roller, both the shaft load and the shell load must be considered. Study for the shaft load covers also the bearing load rating and the study for the shell covers the end cap load rating.
SELECTION AND LOAD RATING OF ROLLER FOR INDOOR CONVEYORS When selecting the roller, both the shaft load and the shell load must be considered. Study for the shaft load covers also the bearing load rating and the study for the shell covers the end cap load rating.
We reserve the right for modifications without prior notice.
SELECTION AND LOAD RATING OF ROLLER FOR INDOOR CONVEYORS When selecting the roller, both the shaft load and the shell load must be considered. The study for the shaft load covers also the bearing load rating and the study for the shell covers the end cap load rating. Selection example: In this case the even load 2800 kg is carried by 8 rollers, roller length 600 mm. Load for one single roller: Roller length L (mm) = GA-rollers = GS- and GK-rollers shaft ends D and E = GS- and GK-rolles shaft end A roller kN 3.5 kN 8 28 8 P F C = = = Select the shaft diameter d = 20 and shaft end alternative D according to diagram 1 (loading capacity of shaft end A is not enough). Check the roller shell load according to diagram 2 and select for the shell 70 x 2.0 (when selecting the diameter take notice the conveyed unit). Based on the points and select roller type GS - 70 x 2.0 - 20D - 600 or GA 70 x 2.0 - 600 Diagram 1: Shaft load Diagram 2: Shell load A B C Based on values L = 600 mm and F C = 3.5 kN A B Roller length L (mm) 1400 88.9 x 2.9 1200 1000 800 600 400 200 1400 1200 1000 800 600 400 200 80.0 x 3.0 80.0 x 1.8 63.5 x 2.9 70.0 x 2.0 F C (N) 10000 F C (N) 5000 2000 1500 1000 400 10000 3000 4000 5000 4000 3000 6000 7000 8000 9000 6000 7000 8000 9000 d 20 d 25 d 25 d 20 d 20 d 17 d 15 d 17 d 15 P = 2800 kg Conveyor Components Sandvik 3/2001 We reserve the right for modifications without prior notice. Roller with shaft end A is loosely fixed to the frame. Loading according to diagram 1. Shaft ends D and E are tightly fixed to the frame and due to a smaller shaft bend their load capacity is higher. Tight fixing junction requires a sturdy frame construction. Loading according to diagram 1. Values in diagram 2 must be multiplied by 0.75, for point load situations. Roller shells with non-standard wall thicknesses are also available. Shell loading values are for an even load. Loading according to diagram 2. Diagram 3 Diagram 4 Standard shaft end alternatives for GS- and GK-rollers Type A Type D Type E d B U M 5 1 2 1 5 1 x 8 M 2 1 M 7 1 2 1 5 1 x 8 M 6 1 M 0 2 ) 5 1 ( 4 1 0 2 x 2 1 M 6 1 M 5 2 8 1 5 2 x 6 1 M 6 1 M Conveyor Components Sandvik