Close the drain cocks and fill the engine with the recommended coolant. Perform the following steps for verifying repairs made to the piston and connecting rod assembly: (a) If new parts such as pistons, rings, cylinder liners or bearings were installed, operate the engine on the run-in schedule.
Gas-Engines and Producer-Gas Plants
A Practice Treatise Setting Forth the Principles of Gas-Engines and Producer Design, the Selection and Installation of an Engine, Conditions of Perfect Operation, Producer-Gas Engines and Their Possibilities, the Care of Gas-Engines and Producer-Gas Plants, with a Chapter on Volatile Hydrocarbon and Oil Engines
Close the drain cocks and fill the engine with the recommended coolant. Perform the following steps for verifying repairs made to the piston and connecting rod assembly: (a) If new parts such as pistons, rings, cylinder liners or bearings were installed, operate the engine on the run-in schedule.
Close the drain cocks and fill the engine with the recommended coolant. Perform the following steps for verifying repairs made to the piston and connecting rod assembly: (a) If new parts such as pistons, rings, cylinder liners or bearings were installed, operate the engine on the run-in schedule.
Close the drain cocks and fill the engine with the recommended coolant. Perform the following steps for verifying repairs made to the piston and connecting rod assembly: (a) If new parts such as pistons, rings, cylinder liners or bearings were installed, operate the engine on the run-in schedule.
6SE483 9610 1996 DETROIT DIESEL CORPORATION From Bulletin 19-60-98 1-288c 33. Close the drain cocks and fill the engine with the recommended coolant. Refer to section 13.8.4, for refilling procedure and refer to section 5.4. NOTE: Coolant system maintenance is very important. Bleed off all the air from the system and top off. 34. Perform the following steps for verifying repairs made to the piston and connecting rod assembly: [a] If new parts such as pistons, rings, cylinder liners or bearings were installed, operate the engine on the run-in schedule. Refer to section 11.7.3.2. [b] If used parts such as pistons, rings, cylinder liners or bearings were installed, refer to section 11.3 for verification of proper piston and connecting rod assembly installation. 1.18 PISTON AND CONNECTING ROD ASSEMBLY All information subject to change without notice. 1-288d From Bulletin 19-60-98 6SE483 9610 1996 DETROIT DIESEL CORPORATION This Page Intentionally Left Blank.
Gas-Engines and Producer-Gas Plants
A Practice Treatise Setting Forth the Principles of Gas-Engines and Producer Design, the Selection and Installation of an Engine, Conditions of Perfect Operation, Producer-Gas Engines and Their Possibilities, the Care of Gas-Engines and Producer-Gas Plants, with a Chapter on Volatile Hydrocarbon and Oil Engines