FDDI is a local area network that uses dual counter-rotating fiber optic token rings operating at 100 Mbps. It uses a primary ring for data transmission and a secondary ring for backup. Data is transmitted in frames using NRZI encoding and 4B/5B encoding. FDDI-2 supports transmission of voice and video. CDDI is the copper version that uses shielded or unshielded twisted pair cabling up to 100 meters.
FDDI is a local area network that uses dual counter-rotating fiber optic token rings operating at 100 Mbps. It uses a primary ring for data transmission and a secondary ring for backup. Data is transmitted in frames using NRZI encoding and 4B/5B encoding. FDDI-2 supports transmission of voice and video. CDDI is the copper version that uses shielded or unshielded twisted pair cabling up to 100 meters.
FDDI is a local area network that uses dual counter-rotating fiber optic token rings operating at 100 Mbps. It uses a primary ring for data transmission and a secondary ring for backup. Data is transmitted in frames using NRZI encoding and 4B/5B encoding. FDDI-2 supports transmission of voice and video. CDDI is the copper version that uses shielded or unshielded twisted pair cabling up to 100 meters.
FDDI [Fiber Distributed Data Interface] is a Local Area Network
(LAN) using Fiber-Optic cable in a [Dual] Token Ring topology. Traffic in each ring flows in opposite directions (counterrotating). The dual-rings consist of a primary and a secondary ring. The primary ring is used for data transmission, while the secondary ring remains idle.The data rate is 100 Mbit/sec. Transmission is defined in a data frame, using (NRZI) (which is self clocking). FDDI uses 4B / 5B encoding.FDDI-2, supports the transmission of voice and video information.Also FFDT; FDDI Full Duplex Technology.Also CDDI; Copper Distributed Data InterfaceAlso SDDI; Shielded twisted-pair Digital Data Interface. Same as CDDI,CDDI uses MLT-3 line coding, which is a threevoltage-level encoding scheme. Uses Shielded Twisted Pair [STP] at 150 ohm impedance, per EIA/TIA 568 or Unshielded Twisted Pair [UTP] at Category 5; per EIA/TIA 568, with a maximum length of 100 metersThe official name for CDDI is: Twisted-Pair Physical Medium Dependent [TP-PMD] orFiberDistributed Data Interface [TP-DDI]
FDDI Data Bus Transfer Timing
Data is sent NRZI. A change in the data level indicates a logic 1, no change indicates a logic 0. The data is sampled every 8nS. CDDI uses MLT-3 line coding, which is a three-voltage-level encoding scheme.
FDDI Online Standards
Information ... Media Access Control (MAC), ..... ANSI X3.139-1987, ISO 9314-2:1989... Physical Layer Protocol (PHY), ..... ANSI X3.148-1988, ISO 9314-1:1989... Physical Layer, Medium Dependent (PMD), ..... ANSI X3.166-1990, ISO 9314-3:1990...
Single Mode Fiber PMD (SMF-PMD), ..... ANSI X3.184-1993,
ISO 9314-4:199x... Low Cost Fiber PMD (LCF-PMD), ..... X3.237-1995, ISO 9314-9:199x... Twisted Pair PMD (TPPMD), ..... X3.263.1995, ISO 9314-10:199x... Physical Layer Repeater (PHY-REP), ..... X3.278-199x