LNL Condensate Water Pump
Installation & Operation Instruction
Shenyang Industry Pump Manufacturing Co. Ltd10.
Table-1.
Contents
Structure description,
Assembly & Disassembly of the Pump,
Cautions during Installation (Assembly)
Installation,
Preparation before start-up,
Start & Running,
Shutdown,
Operation & Maintenance,
Replacement of wear part.1, General
Type LNL condensate water pump is used to feed condensate water and the liquid
which physical and chemical performance similar to water.
The design point performance parameter of the pump: Refer to the contract.
2, Structure description (Refer to the pump structure drawing specified
by the contract)
‘The pump is vertical, double casings centrifugal pump, there is an induced wheel
at its suction. Suction and discharge nozzles of the pump are all above the
foundation. The shaft seal of the pump is mechanical seal, axial thrust is balanced
by pump body. The structure is easy to overhaul, the inlet and outlet pipelines are
not necessary to dismantle when overhaul, the whole work part of the pump can
be lifted out only dismantle the motor.
The pump consists of tow parts: the pump barrel, the work part.
(1) The pump barrel
‘The pump barrel is welded with steel plate, there is a degassing pipe on the
barrel, the gas in pump barrel is drained in to the condensator in time by the
degassing pipe.
(2) The work part
@® pump body
The pump body is divided in two parts, the suction bell mouth pipe and middle
section. The suction bell mouthed pipe is mainly acted as guide flow guide the
liquid absorbed by induced wheel into the first stage impeller the suction bell
mouthed pipe is connected with the middle section.
The middle section acts as the effect of transiting the next stage.
3