TeMiBENII3/2014 |
JRAT 39 DARL 94
|
(ok NAMA ALAT/SPESIFIKASIJABATAN | SPESIFIKASI SYARIKAT
2.2.3 | Tenderer is required to detail out each of
| the part number, description and |
| catatan |
ween
| pemauar
“quantity of each component proposed |
for the said required
| appliance/equipment/software | |
2.2.4 Tenderer will be DISQUALIFIED if the | | | |
quantity and setup requirement are not | |
[meet as required by the above
specification, | | |
| as the proposed wireless acess point by | |
the Tenderer MUST be of the same | |
brand as the wireless controller and
access control server. Failure to comply
| this specification shall result in| |
disqualification of tenderer. | | | |
|
23. mOOOR WIRELESS ACCESS PONT THE | | | 0 |
| iB
2.3.1 | Access Point Specifi
ions
i. Access Point MUST support | |
external antennas
PEGAWAIBERTUGAS TIMBALAN PENGARAHBIL NAMA ALAT/SPESIFIKASI JABATAN
SPESIFIKASI SYARIKAT
office environments |
| ili, Access Point MUST support |
| wireless security module
iv. Access Point MUST support bul
in 802.11ac wave 1 that provides |
a rate of up to 1.3 Gbps
v. Access Point MUST support
Innovative Chipset with RF |
architecture for a high density
experience and cles
technology
technology offering sustained |
1,3-Gbps rates over a greater |
| vii, Access Point MUST support Cross
AP Noise Reduction
Access Point MUST. support |
PEGAWAL BERTUGAS. TIMBALAN PENGARAH
NEGERI
PEMBUAT
13/2014
MUKASURAT 40 DARI 94
KUANTITI
CATATANMUKASURAT 41 DARI 94
Se anmmaarseesuasinaaran | SESHWASSYAREAT | pga | XOAMTTE | _GAATAN
|
band, controller-based | | |
| g02.11a/e/n/ac | | | |
x. Access Point MUST support | | | |
| below 802.11n capabilities: | | |
I Modulararchaeere deseo —7
a. xd MIMO with three spatial
reams | | |
| ) b Maximal ratio combining | | |
\ (MRC) | | |
c. 802.11n and 802.11a/8 | | |
beam forming
| |g. 20-and t0-mte channes | | | |
| fe. PHY data rates up to 450)
Mbps (40 MHz with 5 GHz) | | | | |
| f. Packet aggregation: A-MPDU |
(a/R), A-MSDU (TX/RK) |
g. 802.11 dynamic frequency |
| | selection (DFS) |
cyclic. shift diversity (C50) | | | |
| | support |
|
\ xi. Access Point MUST svopor | | | | |
| | Getow 802 ttaccapabilties: | |
| a. 4x4 MIMO with three spatial | | | | |
cane EZ
WAT BERTUGAS.
TIMBALAN PENGARAHBIL
LON
Las
PEGAW.
fea
AL BE
JAMA ALAT/SPESIFIKASI JABATAN
streams
b. Maximal ratio combining |
802.11ac beam forming
d. 20, 40, and 80-MHz |
channels, |
e. PHY data rates up to 13
Gbps (80 MHz with 5 GHz) |
f Packet aggregation: A-MPDU
(Te/Rx), A-MSDU (TX/Rx) |
g. 802.11 DFS
Access Point MUST come wit
below external antenna:
‘a, 2.4 GHz 2 dBi/5 GHz 4 dBi
Dipole Ant. White RP-TNC
‘Access. Point MUST support |
come with below interface:
‘a. 10/100/1000BASE-T |
autosensing (RI-45)
b. Management console port
(Ri-a5)
Access Point MUST suppo
below powering options:
‘a. 802.3at Pok+
REUGAS.
‘SPESIFIKASI SYARIKAT
NEGERI
PEMBUAT
(ewan
3/2014
1
MUKASURAT 42 DARI 94
—
wuantity |
CATATAN
|
|[Coremmennsr2or
MUKASURAT 43 DARI 94
BIL NAMAALAT/SPESIFIKASI ABATAN SPESIFIKASISYARIKAT NeceR! | yar | CATATAN
“ “_ 7 da [En
Enhanced Pot 1
c. Power injectors
4. Local power supply |
[aw Access Point MUST. suppor |
below IEE standard |
a IEEE 802.114/0/¢, 802.11,
| 802.11h, 802.114 |
b. TEE 802,120¢ brats | |
wi, Access. Point MUST support
security and authentication
| protoco! |
280211, WiFi Protected
Access 2 (WPA2), WPA
| b. 802.1X |
Advanced Encryption |
Standards (AES), Tempo
Key integrity Protocol (TKIP)
|g. Exp transport Laver Securty |
(is)
| e. EAP-Tunneled TLS (TTLS) or | |
Microsoft Challenge |
Handshake Authentication | | |
Protocol Version 2
| (scHarv2) | |
f. Protected EAP (PEAP) v0 or
TIMBALAN PENGARAH
PEGAWATBERTUGASPEGAWALBERTUGA:
NAMA ALAT/SPESIFIKASI JABATAN
| ~~ EAP-MSCHAPV2
g. EAP-Flexible Authentication
via Secure Tunneling (FAST)
| h. PEAP v1 or EAP-Generic
Token Card (GTC)
i. EAP-Subscriber Identity
Module (SIM)
xvii, Aecess Point MUST support Wi-Fi
‘Multimedia (WMM) |
i. Access Point MUST support
Wireless Security Module that
provides full-spectrum, off
channel scanning fora
comprehensive wireless intrusion |
prevention system (wiPS], rogue
detection, context swans |
and radio resource management
(RRM) solutions which scans 2.4-
and 5-GH? channels while serving
data clients on the base dual
band access point platform
xix, Access Point MUST be ready to
support 802.1lac Wave 2
Module |
sft
SPESIFIKASI SYARIKAT
NEGERI
PEMBUAT
eM/BEN/13/2014
MUKASURAT 44 DARI 94
KUANTITI
CATATANUTeM/BEN/13/2014
MUKASURAT 45 DARI 94
fon | mamaria
a " NEGERI 7
CATATAN
channels. | | |
a. 20MHz: 21 |
| noi. paces Pont UST. here on!
| indicator to indicates boot loader
status, association _ status, | |
csemeaetcrae!|
|
Bee cen mae
ane ead |
unit of this switch as per below:
i. B02.11ac Controller AP 4x4:355 |
Modules/Item MUST be included in each | |
23.2 = Lunit
eae ane | | |
i. 2.4 GHe 2.481/5 GHe 4 dBi Dipole |
ie reaeereheerrerearal| | |
Hele
PEGAWAI BERTUG, TIMBALAN PENGARAHTENTS |
ML
CASURAT 46 DARL 94
SIL NAMAALAT/SPESIFKASIJABATAN | —_SPESIFKASISYARIKAT NEGER | QUANTI! | CATATAN
PEMBUAT
- | |
iv. Ceiling Grid Clip for APs -| |
Recessed Mount ~ 1 unit
|v. Power Injector for Wireless
Access Point Series ~ 1 unit
ji, Onsite principal maintenance
requirements for proposed
solutions should meet the | | |
following minimums |
| a. Service Level Agreement
Onsite 8 hours/day x 5
days/week x next business
day hardware replacement
| b. Onsite trouble-shooting and |
replacement of hardware
where required
| c. Able to provide and
reinstalled spare provisioning |
for products covered under
| the contract
d. Tenderer have to provide a
| proof of purchase (certificate
for contract. number from
product manufacturer) of | |
maintenance contract with |
product principle based on | |
r hes Se.
TIMBALAN PENGARAHUTeM/BEN/13/2014
KASURAT 47 DARI 94
MU
FORO n ane cikasisvyaricat |~—=«wNEGERI | ]
ATATAN |
| | NAMA ALAT/SPESIFIKASLJABATAN —__SPESIFIKAS!SYARIKAT pempuar | KUANTITI |
the required service level for
verification, Failure to deliver
this requirement shall be
consider as incomplete
project delivery.
|
|
CAT 6 UTP Point NETCONNECT as
| per below specifications — 1
point for each AP
| a. Operating Temperature
20° to 60°C |
b, ISO/IEC Class /Standard:- |
€/11801:2002
ANSI/TIA/EIA = 568-8
|
d. 3. dB NEXT performance |
above Category 6
e. Lead-free (no heavy metals)
f. Characterized Performance
to 600 MHz
B. 23 AWG |
h, MUST come with 3 meter
factory made workstation
cord
i. MUST come with 2 meter
factory made patch cord |
HON, \
PEGAWATBURTUGABIL NAMA ALAT/SPESIFIKASI JABATAN
| SPESIFIKASI SYARIKAT
- se see esl BOO naa
133 | eer raped oasaoreada|
the part number, description and
quantity of each component proposed
for the —said-_—required
appliance /equipment/software
2.3.4 | Tenderer will be DISQUALIFIED if the
quantity and setup requirement are not
meet as required by the above
specification.
2.3.5 | The proposed wireless access point by
the Tenderer MUST be of the same |
brand as the wireless controller and
access control server. Failure to comply
this specification shall result in
| disqualification of tenderer.
|
2.4 OUTDOOR WIRELESS ACCESS POINT
UTVPEA
Ltecnology that prowdessete |
spectrum intligence for 3 sl
[entering ans tno
TIMBALAN PENGARAH
UTeM/BEN/13/2014
Lu
MUKASURAT 48 DARI 94
[kant | catavan
|
39 |