Professional Documents
Culture Documents
Nebosh-Igc1 2 Papers
Nebosh-Igc1 2 Papers
MANAGEMENT OF INTERNATIONAL
HEALTH AND SAFETY
[DATE]
2 hours, 0930 to 1130
Answer both Section 1 and Section 2. Answer ALL questions.
The maximum marks for each question, or part of a question, are shown in brackets.
Start the answer to each question on the correspondingly numbered page of the answer book.
Answers may be illustrated by sketches where appropriate.
This question paper must be returned to the invigilator after the examination.
SECTION 1
You are advised to spend about half an hour on this section, which contains ONE question.
(ii)
Outline how the organisation might ensure that the nature of the
campaign is effectively communicated to, and understood by, the
employees.
Other than poor communication, describe the organisational factors
that could limit the effectiveness of the campaign.
(8)
(12)
SECTION 2
You are advised to spend about one and a half hours on this section, which contains TEN questions.
Outline reasons for maintaining good standards of health and safety within an
organisation.
(8)
(a)
(b)
(2)
(6)
Outline the key areas that should be addressed in the arrangements section
of a health and safety policy document.
(8)
Employers have a requirement placed upon them under health and safety to
involve their employees.
(i)
(2)
(ii)
(6)
(8)
Outline ways in which the health and safety culture of an organisation might
be improved.
(8)
(2)
(ii)
(6)
(a)
(2)
(b)
10
Outline the immediate and longer term actions that should be taken following a
serious injury accident at work.
(8)
11
List the written information that is likely to be examined during a health and
safety audit.
(8)
[DATE]
2 hours, 1400 to 1600
Answer both Section 1 and Section 2. Answer ALL questions.
The maximum marks for each question, or part of a question, are shown in brackets.
Start the answer to each question on the correspondingly numbered page of the answer book.
Answers may be illustrated by sketches where appropriate.
This question paper must be returned to the invigilator after the examination.
SECTION 1
You are advised to spend about half an hour on this section, which contains ONE question.
(4)
(ii)
(8)
(8)
(iii)
SECTION 2
You are advised to spend about one and a half hours on this section, which contains TEN questions.
Outline the precautions that might be needed to ensure the safety of pedestrians
in vehicle manoeuvring areas.
(8)
(a)
Identify the types of hazard that may cause slips or trips at work.
(4)
(b)
Outline how slip and trip hazards in the workplace might be controlled.
(4)
(a)
(b)
List FOUR specific types of injury that may be caused by the incorrect
manual handling of loads.
(4)
Outline the factors in relation to the load that will affect the risk of injury. (4)
Outline the precautions that should be taken when using mobile cranes.
(8)
(8)
A worker uses a hand-held electric drill regularly in the course of their work.
(i)
Outline the checks that should be made to ensure the electrical safety of
the drill.
(4)
(ii)
(4)
(a)
Outline the effects on the human body from a severe electric shock.
(4)
(b)
Describe how earthing can reduce the risk of receiving an electric shock. (4)
(8)
10
(a)
(2)
(b)
(c)
11
(i)
(1)
(ii)
Ionising radiation.
(4)
(ii)
Non-ionising radiation.
(4)
NEBOSH 2007
Published by the National Examination Board in Occupational Safety and Health (NEBOSH), Dominus Way,
Meridian Business Park, Leicester LE19 1QW. Registered Charity Number 1010444
telephone: 0116 263 4700
email: info@nebosh.org.uk
website: www.nebosh.org.uk