Professional Documents
Culture Documents
GSM Toward 3g
GSM Toward 3g
GSM Toward 3g
A) RBS
B) MSC
C) BSC
D) TRC
2. What are the frequencies bands available for GSM System?
A) GSM 450, GSM 800, GSM 900, GSM 1800 and GSM 1900
B) GSM 800, GSM 900 and GSM 1800
C) GSM 800, GSM 1900 and GSM 1800
D) GSM 900, GSM 1800 and GSM 1900
3. The DTRU must be specified for its _______.
A) Frequency Band and Output Power
B) Output Power
C) Frequency Band and Modulation
D) Frequency Band
4. The ______ Control is performed in the DXU-23.
A) Batteries
B) Fan
C) VSWR
5. The _______ supervises and connects/disconnects the batteries at low voltage.
A) BFU
B) PSU
C) CCU
D) ECU
6. The _________ increases the maximum output power with 2.5dB by using both transmitters of
a DTRU to implement one carrier.
A) Software Power Boost
B) Frequency Hopping
C) RX Diversity
D) Transmitter Coherent Combing (TCC)
7. What is IDM?
A) Installation Data Module
B) Internal Data Module
C) Internal Distribution Module
D) None of above.
15. How many time slots per carrier are there in the GSM system?
A) 8
B) 16
C) 21
D) 4
16. Which logical channel does the mobile use to contact the system?
A) Paging CHannel (PCH)
B) Broadcast Control CHannel (BCCH)
C) Random Access CHannel (RACH)
D) Access Grant Channel (AGCH)
17. How many TRXs can the RBS 6202 handle?
A) 6
B) 12
C) 4
D) 2
18. What is the name of the connection between the DUG and RUG?
A) Y Link
B) C Link
C) Control Link
D) CC Link
19. The DU performs which of the following?
A) Switching, traffic management, timing, Tower Mounted Amplifier Control Module (TMA-CM),
radio interfacing
B) Loadable software (from Flash Card), transmission handling, external synchronization, feeder
loss detection
C) A and B
D) None of the above
20. Which Frequency Band is supported by the RBS 6202?
A) GSM 450, GSM 850, E-GSM, P-GSM, GSM 1800
B) GSM 450, E-GSM, P-GSM, GSM 1800, GSM 1900
C) GSM 450, GSM 850, P-GSM, GSM 1800, GSM 1900
D) GSM 850, E-GSM, P-GSM, GSM 1800, GSM 1900
21. What is the function of the PCU AC?
A) Controls the RBS
B) Responsible for OMT connection with the RBS
C) Terminates the incoming AC cables and distributes to the PSU
D) Signal Modulation/Demodulation and Amplification
22. What is the internal operating voltage used for the RBS 6202?
A) 220 V AC
B) + 24 V DC
C) + 48 V DC
D) -48 V DC
23. What interfaces are used for E1 or T1 connection?
A) TN A and TN B
B) RIA and RIB
C) LMT A and LMT B
D) ET A and ET B
24. How many External Alarms can be connected in the RBS 6202 via the SAU?
A) 8
B) 32
C) 16
D) 10
25. How many cells can the RBS 6202 handle?
A) 4
B) 1
C) 3
D) n
26. Which of the following RUs do not belong to RBS 6202.
A) RUG
B) DUG
C) IDM
D) PDU
27. What is the difference between the RBS 2106 and RBS 2107?
A) Traffic capacity
B) Coverage
C) Suitable environment
D) The RBSs are totally different
28. The Femto Cell Solution can provide access to the network via ___________________.
A) GSM and WCDMA
B) EDGE
C) GSM and CDMA2000
30. When using the LAPD Concentrated, it is possible to control up to ___ TRX in the RBS.
A) 1
B) 2
C) 4
D) 8
31. Ethernet Works on Which Layer
a.) Layer 1
b.) Layer 2
c.) Layer 3
d.) None of the above
32. 2. What is the use of RLIME
a.) It can be used to reserve bandwidth
b.) It is a hop-by-hop label distribution protocol
c.) It helps in configuring Adaptive Bandwidth
d.) It relies on the routing information
33. Which MMU supports Xpic
a.) MMU2E
b.) MMU2C
c.) MMU2F
d.) MMU2D
34. Mac Address is of how many Bits
a.) 48
b.) 32
c.) 24
d.) 128
35. RSTP convergence time
a.) >50 NS
b.) >60 Ns
c.) >70 NS
d.) >80NS
a) R2.0
b) R3.0
c) R4.0
d R5.0
51. Things which cannot be checked in Idle mode drive test.(More than 1 answer)
a) RX Level and RX Quality.
b) RX Level
c) RX Quality
d) Handovers
1. Things which cannot be checked in Idle mode drive test.(More than 1 answer)
52). If RX Level is for coverage and RX Quality for Speech quality in 2G.Select for 3G
a) RSCP for Coverage, EcNo for Quality.
b) RSCP for Quality, EcNo for Coverage.
c) RSCP for handover, EcNo for Quality.
d) None of above.
53. What does ARFCN stand for.
a) Absolute frequency-radio channel number
b) Absolute radio-frequency channel number.
c) Absolute radio-frequency code number.
d) None