Professional Documents
Culture Documents
Lecture 29
Lecture 29
Module 5
Lecture 29
Consolidation-3
Topics
1.1.6 Standard One-Dimensional Consolidation Test and Interpretation
1.1.7 Preconsolidation pressure.
Compression index
cirve
For each load increment, the sample deformation and the corresponding time t is plotted on semilogarithmic
graph paper. Figure 5.26 shows a typical deformation vs. log t graph. The graph consists of three distinct
parts:
1. Upper curved portion (stage I). This is mainly the result of precompression of the specimen.
2. A straight-line portion (stage II). This is referred to as primary consolidation. At the end of the
primary consolidation, the excess pore water pressure generated by the incremental loading is
dissipated to a large extent.
3. A lower straight-line portion (stage III). This is called secondary consolidation. During this stage, the
specimen undergoes small deformation with time. in fact, there must be immeasurably small excess
pore water pressure in the specimen during secondary consolidation.
Figure 5.26 Typical sample deformation vs. log-of-time plot for a given load increment
Note that at the end of the test for each incremental loading the stress on the specimen is the effective stress,
. Once the specific gravity of the soil solids, the initial specimen dimensions, and the specimen
deformation at the end of each load has been determined, the corresponding void ratio can be calculated. A
typical void ratio vs. effective pressure relationship plotted on semilogarithmic graph paper is shown in
Figure 5.27.
plot
2
Figure 5.28 Plot of void ratio vs. effective pressure showing unloading and reloading branches
Based on the above explanation, the two conditions of a soil can be defined
1. Normally consolidated. A soil is called normally consolidated if the present effective overburden
pressure is the maximum to which the soil has ever been subjected,
.
2. Overconsolidated. A soil is called overcosolidated if the present effective overburden pressure is less
than the maximum to which the soil was ever subjected in the past
In Figure 5.28 the branches
are the overconsolidated state of a soil, and the branches
are the normally consolidated state of a soil.
Dept. of Civil Engg. Indian Institute of Technology, Kanpur
In the natural condition in the field, a soil may be either normally consolidated or overconsolidated.
A soil in the field may become overconsolidated through several mechanisms, some of which are
listed in table 2.
The preconsolidation pressure from a e vs. log
plot is generally determined by a graphical
procedure suggested by Casagrande (1936), as shown in Figure 5.29. The steps are as follows:
1. Visually determine the point P (on the upper curved portion of the e vs. log plot) that has the
maximum curvature.
2. Draw a horizontal line PQ.
3. Draw a tangent PR at P.
4. Draw the line PS bisecting the angle QPR.
5. Produce the straight-line portion of the e vs. log plot backward to intersect PS at T.
6. The effective pressure corresponding to point T is the preconsolidation pressure
.
Another method for the determination of
is given in Burmister (1951)
Changes in soil structure due to secondary Raju (1965); Leonards and Ramiah (1960);
compression (aging)*
Leonards and Altschacffl (1964); Bijerrum
(1967, 1972)
Environmental changes such as pH, temperature, Lambe (1958)
and salt concentration
Chemical alteration due to weathering, Bjerrum (1967)
precipitation of cementing agents , ion exchange
Change of strain rate on loading
Lowe (1974)
Compression index
The slope of the e vs. log
From Figure 5.30,
(66)
For normally consolidated clays. Terzaghi and Peck (1967) gave a correlation for the compression index as
(67)
Where LL is the liquid limit. The preceding relation has reliability in the range of
be used for clays with sensitivity ratios greater than 4.
Terzaghi and Peck also gave a similar correlation for remolded clays:
Several other correlations for the compression index with the basic index properties of soils have been made,
and some of these are given below (see Azzouz et al., 1976):
(68)
(69)
(70)
(71)
(72)
Where
Nacci et al. (1975) tested some natural deep-ocean soil samples from the North Atlantic. The calcite content
varied from 10 to 80%. Based on their results, the following equation has also been proposed:
(73)
Where PI is the plasticity index.
cirve
Soil samples obtained from the field are somewhat disturbed. When consolidation tests are conducted on
these samples, we obtain e vs. log
plots that are slightly different from those in the field. This is
demonstrated in Figure 5.31.
curve
(74)
Where e is strain. Again, if an undisturbed laboratory specimen is subjected to the same effective stress
increase, the void ratio will decrease by . Thus, the strain is equal to
(75)
Where
And (2) if
(Figure 5.33c)
(79)