Leaning Tower of Pisa 2014

You might also like

Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 2

Leaning Tower of Pisa, Italian Torre Pendente di Pisa , medieval structure

in Pisa,Italy, that is famous for the settling of its foundations, which caused it to lean
5.5 degrees (about 15 feet [4.5 metres]) from the perpendicular in the late 20th
century. Extensive work was subsequently done to straighten the tower, and its lean
was ultimately reduced to less than 4.0 degrees.
The bell tower, begun in 1173 as the third and final structure of the
cityscathedral complex, was designed to stand 185 feet (56 metres) high and was
constructed of white marble. Three of its eight stories had been completed when the
uneven settling of the buildings foundations in the soft ground became noticeable.
At that time, war broke out between the Italian city-states, and construction was
halted for almost a century. This pause allowed the towers foundation to settle and
likely prevented its early collapse.
Giovanni di Simone, the engineer in charge when construction resumed, sought to
compensate for the lean by making the new stories slightly taller on the short side,
but the extra masonry caused the structure to sink still further. The project was
plagued with interruptions, as engineers sought solutions to the leaning problem, but
the tower was ultimately topped out in the 14th century. Twin spiral staircases lined
the towers interior, with 294 steps leading from the ground to the bell chamber (one
staircase incorporates two additional steps to compensate for the towers lean).
Over the next four centuries the towers seven bells were installed; the largest
weighed more than 3,600 kg (nearly 8,000 pounds). By the early 20th century,
however, the heavier bells were silenced, as it was believed that their movement
could potentially worsen the towers lean.
The foundations have been strengthened by the injection of cement grout and
various types of bracing and reinforcement, but in the late 20th century the structure
was still subsiding, at the rate of 0.05 inch (1.2 mm) per year, and was in danger of
collapse. In 1990 the tower was closed and all the bells silenced as engineers
undertook a major straightening project. Earth was siphoned from underneath the
foundations, decreasing the lean by 17 inches (44 cm) to 13.5 feet (4.1 metres); the
work was completed in May 2001, and the structure was reopened to visitors. The
tower continued to straighten without further excavation, until in May 2008 sensors
showed that the motion had finally stopped, at a total improvement of 19 inches (48
cm). Engineers expected the tower to remain stable for at least 200 years.

Inside the tower there are seven bells. Each bell represents one note of the musical major scale.

Nobody seems to be able to pinpoint the identity of who the actual original architect really was.

The Leaning Tower of Pisa is a circular shape and has eight floors. The 7 bells are located on the eighth
floor.

Some people have suggested that the tower should be straightened. The people have Pisa had said they
would rather see it fall over than be straightened.
The construction of this imposing mass was started in the year 1174 by Bonanno Pisano. When the
tower had reached its third storey the works ceased because it had started sinking into the ground. The
tower remained thus for 90 years. It was completed by Giovanni di Simone, Tommano Simone (son of
Andreo Pisano).

It can be considered a real masterpiece of architecture, this monument is mostly famous for its strong
inclination. Regarding this inclination it can be safely stated that it is undoubtedly due to a sinking of the
ground right from the time of its construction. Therefore, the assumption of those who desire to
imagine that great tower was built inclined is entirely without foundation.

Unfortunately, even today the great mass continues to sink very slowly. It is a question of about 1 mm.
every year.

You might also like